Instruction manual

30
lowes.com/masterforge
®
TROUBLESHOOTING
PROBLEM POSSIBLE CAUSE CORRECTIVE ACTION
Grill or side cooker
will not light.
1. The ignition wire came off the
electrical igniter/valve.
2. The distance between the ignition
pin and the burner is greater than
5/32 in.-3/16 in. (side burner).
3. The ignition wire is broken.
4. The battery died.
5. The battery is in the wrong
polarity.
6. The electrode tip does not
produce sparks at the burner
port.
7. No gas supplied.
8. Air shutter opening is to big.
1. Reconnect the ignition wire to the
electrical igniter/valve.
2. Loosen the ignition pin and adjust
the distance, then fasten it again.
3. Call customer service for a
replacement ignition wire.
4. Install a new AA battery.
5. Change the battery polarity.
6. Reinstall the electrode.
7. Turn on the regulator valve.
8. Loosen the air shutter and adjust
the opening to a smaller size
yellow and gas odor
can be smelled.
1. Spiders or insects block air
shutter.
1. Clean blockages, check for the
source of gas leaks.
1. Grilling fatty meats.
2. Knobs on “HIGH”.
4. Hood closed when grilling.
1. Grill fatty meats when the grids are
cold while the knobs are on the
“LOW” setting. Move the meats
2. Before you are ready to grilling, turn
the knobs to the “OFF”.
4. Hood up when grilling.
Burner blows out
1. LP tank is empty.
2. Burner is not aligned with the
control valve.
2. Install the burner correctly.
3. Check the gas supply hose and
make sure there are no leaks and
no knots.