Service Manual
Table Of Contents
- Cover Page
- Section 0 (Table of Contents)
- Section 1 (Introduction)
- Section 2 (Sealed System)
- Section 3 (Sealed System Components)
- Section 4 (Electrical Component Access)
- Section 5 (User Interface Display)
- Section 6 (Control System)
- Section 7 (Lights, Doors, Drawer, and Hinges)
- Section 8 (Evaporator Compartment Access)
- Section 9 (Wiring Diagrams)
- Section 10 (Power On reset Mode)
- Section 11 (Quick Reference Troubleshooting)
- Section 12 (Diagnostic Flow Charts)
- Section 13 (Gathering Service Data)
- Section 14 (Beer Dispenser)
- Section 15 (Dual Zones)
- 15.1: User Interface Control
- 15.2: Operation
- 15.3: Characteristics
- 15.4: Dual Zone Compartment Air Flow
- 15.5: Divider Removal
- 15.6: Damper Operation
- 15.7: Compartment Fan Operation
- 15.8: Heater Operation
- 15.9: Thermistors
- 15.10: Evaporator Access
- 15.11: Interior LED’s
- 15.12: Defrost / Drip Time
- 15.13: Refrigeration and Mechanical
- Section 16 (Refrigerator Freezers)
- Section 17 (Outdoor Models)
- 17.1: Operation
- 17.2: Characteristics / Differences
- 17.3: Fans
- 17.4: Thermistors
- 17.5: Control Type
- 17.6 : Control Functions
- 17.7: Control Locations per Model
- 17.8: Machine Compartment
- 17.9: Main Power Board Access
- 17.10: Display Access and Replacement
- 17.11: Thermistor Resistance
- 17.12: Wiring Diagram
- 17.13: Generic Trouble shooting Charts
- 17.14: Refrigeration and Mechanical
- Section 18 (Prime Control)
- Section 19 (Clear Ice Machines)
- Section 20 (Service Kits / Bulletins)
- 20.1: Service Bulletin # 41013862Mullion Condensation on Refrigerated Drawers
- 20.2: SERVICE BULLETIN # 41013861EVAPORATOR REPLACEMENT KIT
- 20.3: SERVICE BULLETIN # 41013995 Rev CContact between the Door and Door Sensor
- 20.4: SERVICE BULLETIN # 41014167Slotted Condenser Shroud
- 20.5: SERVICE BULLETIN # 41014168Showroom Mode Alarm
- 20.6: SERVICE BULLETIN # 41014169Evaporator / Heat Exchanger Replacement(RF and RFI Models ONLY)
- 20.7: SERVICE BULLETIN # 41014241Shelf Shim Kit
- 20.8: Service Bulletin # 41014242Miscellaneous Control Communication Errors
- 20.9: Service Bulletin # 41014243Replacement of MP Door Skins
- Section 21 (Customer Service Contact Information)
- Section 22 (Notes)
- Back Page
1
Section 1: Introduction
1.1 Unit Specifications:
(Single Zone) WINE COOLERS, BEVERAGE CENTERS, ALL REFRIGERATORS
Performance Data: No Load & No Door Openings @ Control Setting of Mid
Type A with Run Capacitor
65°F (18°C) Ambient
90°F (32°C) Ambient
Operating Time
8 - 15% (wine cooler)
15 - 35% (beverage center / refrigerator)
20 - 40% (wine cooler)
35 - 55% (beverage center/refrigerator)
Wine Cooler Temperature
40°F - 65°F
40°F - 65°F
Beverage Center / All Refrigerator Temperature
34°F - 42°F
34°F - 42°F
Low Side Pressure (cut in)
25 - 50 psig (172 - 345 kPa)
25 - 50 psig (172 - 345 kPa)
Low Side Pressure (cut out)
0 - 10 psig (0 - 69 kPa)
0 - 10 psig (0 - 69 kPa)
HIgh Side Pressure (last 1/3 of cycle)
95 - 125 psig (655 - 862 kPa)
130 - 175 psig (896 - 1207 kPa)
Wattage (last 1/3 of cycle)
55 - 80
55 - 80
Amps (running)
.45 - .85
.45 - .85
Base Voltage
115 VAC (127 VAC max)
115 VAC (127 VAC max)
R-134A Charge in Ounces: 3.0
Compressor
120 volt/60 hertz
BTU/HR: 200
LRA: 5.22
Condenser Fan Motor
Watts
RPM
Amps
4.1
1280
0.06
Evaporator Fan Motor
Watts
RPM
Amps
1.08
2550
0.09
REFRIGERATED DRAWERS
Performance Data: No Load & No Door Openings @ Control Setting of Mid
Type A with Run Capacitor
65°F (18°C) Ambient
90°F (32°C) Ambient
Operating Time
8 - 15%
20 - 40%
Temperature
34°F - 42°F
34°F - 42°F
Low Side Pressure (cut in)
25 - 50 psig (172 - 345 kPa)
25 - 50 psig (172 - 345 kPa)
Low Side Pressure (cut out)
0 - 10 psig (0 - 69 kPa)
0 - 10 psig (0 - 69 kPa)
HIgh Side Pressure (last 1/3 of cycle)
95 - 125 psig (655 - 862 kPa)
130 - 175 psig (896 - 1207 kPa)
Wattage (last 1/3 of cycle)
55 - 80
55 - 80
Amps (running)
.45 - .85
.45 - .85
Base Voltage
115 VAC (127 VAC max)
115 VAC (127 VAC max)
R-134A Charge in Ounces: 3.0
Compressor
120 volt/60 hertz
BTU/HR: 200
LRA: 5.22
Condenser Fan Motor
Watts
RPM
Amps
4.1
1280
0.06
Evaporator Fan Motor
Watts
RPM
Amps
1.08
2550
0.09