Instruction Manual

Freeze-dryer EPSILON 1-4 LSCplus
Freeze-dryer EPSILON 2-4 LSCplus
6 Operation
40
Version 04/2014, Rev. 1.4 of 09/12/2014 • sb
Translation of the original operating manual
Pos: 114 /20 0 Ch rist/3 60 G T-BA Labo r-Pi lot (STAN DA RDMODU LE )/0 60 Bet rieb0 60 Be tri eb== == ===== == ===== ==== === ==== ===== == ===== = @ 25\ mod_14 0498 375 975 8_68. doc x @ 1835 78 @ 1 @ 1
6 Operation
Pos: 115 /20 0 Ch ris t/3 60 G T-BA L abo r-Pi lot (STA NDA RDMOD U LE)/0 60 B et rieb0 60 -0010 E rs te I nbet rieb nah me+++ ++ +++++ ++ +++++ ++ +++++ ++ @ 2 5\mo d_1404 983 760 674 _68. docx @ 18 359 2 @ 2 @ 1
6.1 Initial start-up
WARNING
Before the initial start-up, please ensure that your freeze-dryer is properly
set up and installed (see chapter 5 - "Set-up and connection")
Pos: 116 /01 0 Uni v ersal mod ule/L eerz ei le @ 0\m od_ 120 211624 450 0_0. doc x @ 11 4 @ @ 1
Pos: 117 /20 0 Ch rist/3 60 G T-BA L abo r-Pi lot (STAN DAR DMODU LE )/0 60 Bet rieb0 60 -0020 I nstall a tion v on Zub ehö rko mpo nent en+++ ++ +++++ +++++ ++ +++++ @ 25\ mod_ 140 4983 761 840_68. doc x @ 18 360 7 @ 2 @ 1

6.2 Installation of accessories
The accessories must be completed in accordance with the drying method
that is applied as well as in accordance with the scope of supply.
The installation instructions can be found in a separate document. Please
contact our sales department if you have any queries.
Pos: 118 /01 0 Uni v ersal mod ule/L eerz ei le @ 0\m od_ 120 211624 450 0_0. doc x @ 11 4 @ @ 1
Pos: 119 /20 0 Ch rist/3 60 G T-BA L abor-P ilot (STA NDA RDMOD U LE)/0 60 Bet ri eb060 -003 0 Vo rbe reitu ng +++++ ++ +++++ ++ +++++ ++++ +++ ++++ +++ + @ 25\ mod _14 0498 376 2863_6 8.do cx @ 1 836 20 @ 2 @ 1
6.3 Preparation
The ice condenser chamber must be clean and dry.
• Remove any water residues from the preceding run.
• Close the media drain valve and the aeration valve.
• Ensure that all of the valves of the accessories are closed.
• Switch the vacuum pump on.
Pos: 120 /01 0 Uni v ersal mod ule/L eerz ei le @ 0\m od_ 120 211624 450 0_0. doc x @ 11 4 @ @ 1
Pos: 121 /20 0 Ch rist/3 60 G T-BA L abo r-Pil ot (S TANDA RDMOD U LE)/0 60 Bet rieb0 60 -004 0 Einsc halte n ( nur N etzsc halte r) +++++ ++++ +++ ++++ +++++ ++ +++++ ++++ +++ +++ @ 25\mod_ 140 498 376 4944_68 .doc x @ 1 836 48 @ 2 @ 1
6.4 Switching the freeze-dryer on
• Actuate the mains power switch.
The control unit performs a self-test and an initialisation. This may take
several seconds.
• Follow the safety instructions and hazard warnings (see chapter 3 -
"Safety")!
Pos: 122 /01 0 Uni v ersal mod ule/S eit enwec hsel @ 0\m od_ 120 211 624 4312 _0. docx @ 10 5 @ @ 1