Troubleshooting guide

Form No. S-4846 Rev. A 11/98
3. OPERATION (cont’d.)
3-3
3. Turn power switch off and drain the steam genera-
tor that needs cleaning.
4. Turn the power switch on.
5. Remove the cleaning solution inlet cap located on
the right hand side of the upper brow.
6. Using a kitchen funnel, pour Market Forge’s TOTAL
CONCEPT™ deliming solution (P/n 20-0318) into the
generator (2 quarts).
7. Add 5 quarts of water to fill the generator to
3
/
4
. The
heater relay will click on.
CAUTION
Read directions and information on TOTAL CON-
CEPT™ deliming solution container before us-
ing.
8. Allow the unit to preheat until the red “READY” light
comes on.
9. After the ready light is on, set the timer for about
1 hour.
10. When timer has counted to zero and the buzzer
sounds, the “clean” light should be off. If the light is
not off, repeat Step 10.
11. Now the system needs to be rinsed, which is ac-
complished by:
• turning the power off (the unit drains)
• turning the water supply on at its source
• turning on the power permitting water to enter
the generator
• allowing the unit to reach preheat conditions
(green light on)
• setting timer for 10 minutes
• draining the rinse water after the buzzer sounds
by turning off the power.
After rinse water is drained, turn the power on, wait
for the steam ready light, and you are ready to cook.
3.4 DRAINAGE
3.4.1 Cooking Compartment Drainage
The bottom of the cooking compartment is angled
slightly toward the rear of the unit. This assures that any
condensate build-up or spills will be directed toward the
drain hole, which is located at the rear bottom center of
the cooking compartment. Any liquid exiting the cooking
compartment runs down the cooking compartment drain
tube and into the condenser box, where it is cooled down
to temperatures below 140°F prior to entering the drain
line.
3.4.2 Drip/Spill Trough Drainage
The ST-6 TGG pressureless steam cooker has a drip/
spill trough below the bottom cooking compartment door.
It will catch any condensate gathering on the front of the
unit when the door is opened.