User Manual

18 Part Number 000015236 Rev 00 11/17
Installation Instructions Section 2
Installation Check List
All Manitowoc ice machines are factory-operated and
adjusted before shipment. Adjustments and maintenance
procedures outlined in this manual are the responsibility of
the owner/operator and are not covered by the warranty.

Is the ice machine level?

Is the ice machine and adapter (when used) secured to
the dispenser?

Have all of the electrical and water connections been
made?

Has the supply voltage been tested and checked against
the rating on the nameplate?

Is there proper clearance around the ice machine for air
circulation?

Is the ice machine grounded and polarity correct?

Has the ice machine been installed where ambient
temperatures will remain in the range of 50° - 110°F
(10° - 43°C)?

Has the ice machine been installed where the incoming
water temperature will remain in the range of 37° - 90°F
(3° - 32°C)?

Is there a separate drain for the water-cooled
condenser?

Is there a separate drain for the dispenser?

Is the ice making water turned on?

Are all electrical leads free from contact with
refrigeration lines and moving equipment?

Has the owner/operator been instructed regarding
maintenance and the use of Manitowoc Cleaner and
Sanitizer?

Has the owner/operator completed the warranty
registration card?

Has the ice machine and bin been sanitized?

Is the rocker switch set to ON?
Additional Checks for QuietQube Models

Is the line set length, rise and drop within the
guidelines?

Are the suction and liquid line shut-off valves open?

Is the line set routed properly?

Are both refrigeration lines to remote condensing
unit run so they do not lay in water and are properly
insulated?

Does the condenser fan motor(s) operate properly after
start-up?

Have all the refrigeration fittings and joints been leak
checked?

Has the condenser/condensing unit been installed to
prevent any roofing damage?

Have the refrigeration lines been insulated and secured
properly to prevent vibration?

Has the RCUF remote condensing unit been located
where ambient temperatures will remain in the range of
-20° to 120°F (-29° to 48.9°C)?

Is a refrigeration oil trap (S-trap) installed if the
condenser is installed 21 to 35 feet (6 to 11 m) above
the ice machine head?