Service Manual
Table Of Contents
- Safety Notices
- Definitions
- General Information
- Installation
- Stacking Two Ice Machines on a Single Storage Bin
- Location of Ice Machine
- Clearance Requirements
- Dual Evaporator Model Installation on a Manitowoc Bin
- Ice Machine on a Dispenser Installation
- Water Supply and Drains
- Lineset Applications
- QuietQube® Remote Condensing Unit
- Additional Refrigerant Charge For 51' to 100' Line Sets
- Maintenance
- Operation
- Menu Navigation
- Component Check Procedures
- Control Board, Display And Touchscreen
- Operating an ice machine without a Touchscreen
- Control Board Relay Test
- Programming A Replacement Control Board
- USB Flash Drive Specifications and Formatting
- Exporting Data to a Flash Drive
- Upgrading Firmware with a Flash Drive
- Main Fuse
- Bin Switch
- Water Level Control Circuitry
- Ice Thickness Probe (Initiates Harvest)
- Bin Level Probe
- Thermistors
- High Pressure Cutout (HPCO) Control
- Low Pressure Cutout (LPCO) Control
- Compressor Time Delay
- Fan Cycle Control
- Harvest Assist Air Pump
- Compressor Electrical Diagnostics
- Diagnosing Start Components
- Refrigeration Components
- Recovery/Evacuation/Charging Procedures QuietQube® Models
- System Contamination Clean-Up
- Total System Refrigerant Charge QuietQube® CVD Models
- Control Board, Display And Touchscreen
- Charts
- Diagrams
34 Part Number: 000015431 Rev 02 6/20
QuietQube® Remote Condensing Unit
QuietQube® Ice
Machine
Remote Single
Circuit Condenser
Line Set* S Trap
IF0600C
IBF0620C
CVDF0600
RC-21
RC-31
RC-51
K00172
IBF0820C
IF0900C
CVDF0900
IBT1020C CVDT1200
IT1200C CVDT1200
IF1400C CVDF1400 RC-20
RC-30
RC-50
K00166
IF1800C CVDF1800
IF2100C CVDF2100
RC-23
RC-33
RC-53
*Line Set
Suction
Line
Liquid
Line
Minimum
Insulation
Thickness
RC 21/31/51
5/8 inch
(16 mm)
3/8 inch
(10 mm)
1/2" (13 mm)
Suction Line
1/4" (7 mm)
Liquid Line
RC 20/30/50
3/4 inch
(19 mm)
1/2 inch
(13 mm)
1/2"(13 mm)
Suction Line
1/4" (7 mm)
Liquid Line
RC 23/33/53
3/4 inch
(19 mm)
5/8 inch
(16 mm)
1/2" (13 mm)
Suction Line
1/4" (7 mm)
Liquid Line