Service Manual
Table Of Contents
- Safety Notices
- Definitions
- General Information
- Installation
- Stacking Two Ice Machines on a Single Storage Bin
- Location of Ice Machine
- Clearance Requirements
- Dual Evaporator Model Installation on a Manitowoc Bin
- Ice Machine on a Dispenser Installation
- Water Supply and Drains
- Lineset Applications
- QuietQube® Remote Condensing Unit
- Additional Refrigerant Charge For 51' to 100' Line Sets
- Maintenance
- Operation
- Menu Navigation
- Component Check Procedures
- Control Board, Display And Touchscreen
- Operating an ice machine without a Touchscreen
- Control Board Relay Test
- Programming A Replacement Control Board
- USB Flash Drive Specifications and Formatting
- Exporting Data to a Flash Drive
- Upgrading Firmware with a Flash Drive
- Main Fuse
- Bin Switch
- Water Level Control Circuitry
- Ice Thickness Probe (Initiates Harvest)
- Bin Level Probe
- Thermistors
- High Pressure Cutout (HPCO) Control
- Low Pressure Cutout (LPCO) Control
- Compressor Time Delay
- Fan Cycle Control
- Harvest Assist Air Pump
- Compressor Electrical Diagnostics
- Diagnosing Start Components
- Refrigeration Components
- Recovery/Evacuation/Charging Procedures QuietQube® Models
- System Contamination Clean-Up
- Total System Refrigerant Charge QuietQube® CVD Models
- Control Board, Display And Touchscreen
- Charts
- Diagrams
Table of Contents
Part Number: 000015431 Rev 02 6/20 13
Safety Notices ...............................3
Definitions ..............................4
General Information
Model Numbers ............................19
QuietQube® Models .....................19
How to Read a Model Number ................20
Head Sections ..........................20
CVD Condensing Units ...................21
Ice Cube Sizes ..............................21
Model/Serial Number Location................22
Warranty ..................................23
Warranty Registration....................23
LuminIce® II ................................24
Installation
Stacking Two Ice Machines on a Single Storage
Bin....................................25
Ice Deflector ...........................25
Location of Ice Machine ......................26
Head Section ...........................26
Ice Beverage Models.....................27
Location of CVD Condensing Units .........28
Clearance Requirements .....................29
Dual Evaporator Model Installation on a Manitowoc
Bin........................................30
Ice Machine on a Dispenser Installation ........31
Water Supply and Drains .....................32
Lineset Applications .........................33
QuietQube® Remote Condensing Unit ..........34
Additional Refrigerant Charge For 51' to 100' Line
Sets .......................................35