Installation Sheet

Majestic • ECHEL36IN-C/STIN-C, ECHEL48IN-C/STIN-C, ECHEL60IN-C, ECHEL72IN-C Installation Manual • 2608-980 Rev. C • 8/192
Safety Alert Key:
• DANGER! Indicates a hazardous situation which, if not avoided will result in death or serious injury.
• WARNING! Indicates a hazardous situation which, if not avoided could result in death or serious injury.
• CAUTION! Indicates a hazardous situation which, if not avoided, could result in minor or moderate injury.
• NOTICE: Used to address practices not related to personal injury.
Table of Contents
Installation Standard Work Checklist ....................3
1 Product Specic and Important Safety Information
A. Appliance Certication ............................4
B. Glass Specications ..............................4
C. BTU Specications ...............................4
D. High Altitude Installations .......................... 4
E. Non-Combustible Materials Specication. . . . . . . . . . . . . . 5
F. Combustible Materials Specication .................5
G. Electrical Codes .................................5
H. California ......................................5
I. Requirements for the Commonwealth of Massachusetts . . 6
2 Getting Started
A. Design and Installation Considerations ...............7
B. Good Faith Wall Surface .......................... 8
C. Tools and Supplies Needed ........................9
D. Inspect Appliance and Components ..................9
3 Framing and Clearances
A. Appliance/Decorative Barrier Front Dimension Diagrams 10
B. Appliance Location and Clearances to Combustibles ...15
C. Constructing the Appliance Chase .................. 19
D. Floor Protection ................................20
4 Termination Location and Vent Information
A. Approved Pipe .................................21
B. Vent Termination Minimum Clearances .............. 21
C. Vent Terminal Clearances ........................22
D. Use of Elbows .................................23
E. Vent Diagrams .................................24
5 Vent Clearances and Vent Framing
A. Vent Clearances to Combustibles .................. 33
B. Wall Penetration Framing/Firestops .................34
C. Ceiling Firestop/Floor Penetration Framing ...........35
D. Install Attic Insulation Shield .......................35
6 Appliance Preparation
A. Top Standoff Preparation .........................36
B. Prepare For Heat Management ....................37
C. Securing and Leveling the Appliance ................ 38
D. Installing Non-Combustible Facing Material .......... 39
7 Venting
A. Assemble Vent Sections (DVP Pipe Only) ...........40
B. Assemble Slip Sections ..........................42
C. Secure the Vent Sections .........................42
D. Disassemble Vent Sections ....................... 43
E. Vertical Termination Requirements ..................44
F. Horizontal Termination Requirements ...............45
8 Electrical Information
A. General Information .............................47
B. Wiring Requirements ............................49
9 Gas Information
A. Fuel Conversion ................................51
B. Gas Pressure .................................. 51
C. Gas Service Access .............................51
D. Gas Connection ................................53
E. High Altitude Installations .........................53
F. Air Shutter Setting ..............................54
10 Finishing
A. Facing Material .................................55
B. Decorative Barrier Fronts .........................59
C. Mantel and Wall Projections .......................64
11 Appliance Setup
A. Fixed Glass Assembly Removal and Replacement .....67
B. Remove the Shipping Materials/Install Bottom Glass
Shield ........................................67
C. Clean the Appliance .............................68
D. Install Glass Refractory (Optional) .................68
E. Install Log Set or Stones (Optional) ................68
F. Install Media (Included) ..........................68
G. IntelliFire™ Touch Control System Setup .............71
12 Reference Materials
A. Vent Components Diagrams ......................72
B. Accessories ...................................78
 = Contains updated information.


