Specifications

5
ENGINE SAFETY
Internal combustion engines present special hazards during operation and fueling! Failure to follow the
safety guidelines described below could result in severe injury or death. Also read and follow all safety
warnings described in the Engine Operators Manual. A copy of this manual was supplied with unit when
it was shipped from the factory.
• DO NOT run engine indoors or in an area with poor ventilation unless exhaust hoses are used. Diesel
engine exhaust contains carbon monoxide, a deadly, odorless and colorless gas which, if inhaled,
can cause nausea, fainting or death. Make sure engine exhaust cannot seep into closed rooms or
ventilation equipment.
• DO NOT fill fuel tank near an open flame, while smoking, or while engine is running. DO NOT fill tank
in an enclosed area with poor ventilation.
• DO NOT operate with the fuel tank cap loose or missing.
• DO NOT operate on a combustible surface.
• DO NOT touch or lean against hot exhaust pipes or engine block.
• DO NOT clean air filter with gasoline or other types of low flash point solvents.
• DO NOT remove engine coolant cap while engine is hot.
• DO NOT operate the unit without a functional exhaust system. Prolonged exposure to sound levels
in excess of 85 DBA can cause permanent hearing loss. Wear hearing protection when working around
a running engine.
• Keep hands, feet and loose clothing away from moving parts on the pump and engine.
• Keep area around exhaust pipes and radiator free of debris to reduce the chance of an accidental fire.
• Batteries contain sulfuric acid which can cause severe injury or death. Sulfuric acid can cause eye
damage, burn flesh or eat holes in clothing. Protective eye wear and clothing are necessary when
working on or around the battery. Always disconnect the NEGATIVE (-) battery cable from the
corresponding terminal before performing any service on the engine or other components.
• Shut down the engine if any of the following conditions exist during operation:
1. Noticeable change in engine speed.
2. Loss of pumping output.
3. Sparking occurs.
4. Engine misfires or there is excessive engine/pump vibration or noise.
SERVICE SAFETY
Only a qualified electrician should troubleshoot or repair electrical problems occurring in this equipment.
• Before servicing the trash pump, make sure the engine start switch is turned to OFF and the negative
terminal on the battery is disconnected. NEVER perform even routine service (oil/filter changes,
cleaning, etc.) unless all electrical components are shut down.
• NEVER service electrical components if clothing or skin is wet. If the unit is stored outside, check the
engine for any moisture and dry the unit before use.
• NEVER open the radiator cap or oil drain plug while the engine is running or before the engine has
cooled down. Pressurized coolant and hot engine oil can cause severe burns. Allow the engine to
cool completely before attempting any service work.
• NEVER attempt to modify the engine, pump or related components.
• NEVER wash the unit with a power washer or high pressure hose.
• Keep hands, feet, hair and loose clothing away from moving parts.
• Replace all guards and safety devices immediately after servicing.