User Manual

4|Page
Install Procedure – NPT Adapters
1. Place one of the union nuts over an NPT tail piece
• Make sure to use plumber’s tape on the NPT thread
2. Install Flowmeter adapter to the piping on the UV chamber’s Inlet.
• Flowmeter must be installed horizontally.
• Place the rubber washer inside of the union nut and aach the Flowmeter to the union nut
• The ow direcon arrows MUST poinng to the inlet of the UV chamber.
• The union nut only needs to be hand ghtened.
4. Place the other union nut over the other NPT tail piece, place the rubber washer inside of the union nut
and aach the adapter to the other side of the Flowmeter
• The union nut only needs to be hand ghtened.
5. Prepare/measure the required piping to install to the NPT adapter
• Make sure that the length of pipe on the inlet to the Flowmeter is 10 mes the diameter of
the pipe. Refer to specicaons for lengths.
6. Remove the Flowmeter, and install the piping to the NPT adapter.
• Do not apply any heat to the piping or sweat adapters with the Flowmeter installed, this
could potenally damage the rubber washer and Flowmeter creang a major leak.
7. Install the piping to the NPT adapter
• Make sure to use plumbers’ tape on the NPT thread
8. Install the Flowmeter back to the union nuts of the NPT adapters.
• The ow direcon arrows MUST be poinng to the inlet of the UV chamber.
• The union nut only needs to be hand ghtened, allows for easy maintenance.
Module Installaon
Once the Flowmeter and the UV system has been plumbed:
Step 1) Power o the BLACKCOMB or BLACKCOMB-HO controller.
Step 2) Plug in the AC/DC wall adapter (5V Max) into the power port on the Flowmeter.
Step 3) Plug the male plug of the Flowmeter into the IEP (Innite Expandability Port) on the controller, or
into any other LUMINOR module that contains an IEP (sensor, 4-20mA module, solenoid module,
etc).
Step 4) Power on the system and the controller will detect and inialize the Flowmeter module during the
start-up sequence.
Sensor IEP
Installaon
IEP
connecon
BLACKCOMB
Controller
BLACKCOMB-HO
Controller
IEP
connecon
IEP
connecon