SIT-TO-STAND PATIENT LIFT Models LF2020 & LF2090 OWNER’S MANUAL LF2020-INS-LABRevB06 ©GF Health Products, Inc.
CONTENTS INTRODUCTION . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . .4 SPECIAL NOTES . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . .4 SAFETY PRECAUTIONS . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . .5-6 FEATURES . . . . . . . . . . . . . . . .
INTRODUCTION Congratulations on your purchase of a Lumex patient lift. The following pages will provide you with important safety and operating instructions on the use of patient lifts, slings, and accessories, as well as maintenance and warranty information. Read this manual carefully before operating your patient lift and refer to it as often as needed.
MAINTENANCE Maintenance MUST be performed by qualified personnel ONLY. Note: The information contained in this document is based on the latest product information available at the time of publication. GrahamField reserves the right to make changes at any time without notice. Caution: Caution notices as used in this manual apply to hazards or unsafe practices Note: In this manual, the person being lifted is that could result in property damage.
Warning: The LF2020/LF2090 Sit-To-Stand Patient Lift should be used solely for transferring a patient from one object (beds, bathtubs, toilets, etc.) to another. The lift should not be used for transporting or moving any patient from one location to another location. Warning: Always keep the patient being lifted centered over the base and facing the caregiver operating the lifter. Warning: Do not roll casters over any object while the user is in the sling.
FEATURES 1. Base2. Mast3. Control Box4. Pendant5. Actuator6. Lifting Boom7. Kneepad Assembly8. Footrest9. Brake- HANDLING PROCEDURES SHIPPING AND TRANSPORTATION INSTRUCTIONS If the patient lift is to be reshipped by common carrier, it should be packed in the same carton/s in which it was received. Unpacking Inspection 1. Check for any obvious damage to the carton 1. Examine the exterior of the patient lift for or its contents. If damage is evident, notify nicks, dents, scratches or other damage.
ASSEMBLY INSTRUCTIONS 1. Open the box and take lift out. 2. Unscrew nuts and bolts at top and bottom of the mast. 3. With one hand on the mast and another on the boom, stand the mast up. 4. Put bolts through the bottom two holes at the base of the mast and hand tighten them. 5. Attach boom to mast and hand tighten bolt and nut. 6. Attach the L-shaped arms to back of the kneepad. For desired height of the kneepad, use proper holes on the L-shaped arms. 7. Attach kneepad assembly to the mast. 8.
OPERATING INSTRUCTIONS Preparation Before Lifting 1. Turn on the power by twisting the RED RESET 3. After the battery indicator lights go out, push the UP button and the DOWN button on the BUTTON clockwise. hand control and ensure that the lift is operating correctly. 2. Press the UP or DOWN button on the hand control once. Check if the battery indicator lights are on. To proceed with lifting, make 4. Position of the base of lift around or under the object. sure there is at least one green light.
Lift and Transfer From Bed 1. Fit sling as described in “Fitting Lumex 10. Transfer to another object can be done at this position without the patient attending a full Sit-To-Stand Sling”. standing position. 2. Push lift towards patient. Open the base of the lift. Apply the brakes on both rear 11.Release the brakes, close the base, and pull the lift away from the bed. casters. 3. Position patient’s feet on the foot platform 12. Lower the patient to the object intended. and knees against the knee pad. 13.
Lift and Transfer From Chair 1. Fit sling as described in “Fitting Lumex 10. Transfer to another object can be done at this position without the patient attending a full Sit-To-Stand Sling”. standing position. 2. Push lift towards patient. Open the base of the lift to go around the chair. Apply the 11.Release the brakes, close the base, and pull the lift away from the chair. brakes on both rear casters. 3. Position patient’s feet on the foot platform 12. Lower the patient to the object intended.
1. Check batteries by pressing the Battery Testing Button (blue circle with a battery sign) on the control box. 2. Batteries are fully charged when all lights on the Battery Indicator are "ON". 3. Charge batteries when Indicator shown only one “GREEN” light. 4. Do not use the lift when no “GREEN” light is shown. Charge the batteries immediately. 5. Replace batteries when frequent charging is needed. (Reorder #: DPL650BAT) charge the batteries from one green light. 6.
CARE AND MAINTENANCE Proper care and maintenance is essential to (such as automobile lubricant) should be applied keeping your Lumex patient lift in safe operating to the ball bearings of the casters every six (6) months. Apply grease more frequently if the condition. casters are exposed to periods of excess In addition to inspecting the unit before each use, moisture. Lubricate all pivot points with periodic maintenance checks should be done as lightweight oil. Clean patient lift of all excess oil needed.
MAINTENANCE SCHEDULE Note: Only qualified persons should service and repair your Lumex patient lift. Regular maintenance of your patient lift is necessary to ensure continuing proper and safe operation.
TROUBLESHOOTING Warning: If you experience a problem with your lift and are unable to service it yourself, contact your Graham-Field Health Products dealer.
SPECIFICATIONS Note: All dimensions given in inches unless otherwise specified. LF2020/LF2090 SIT TO STAND PATIENT LIFT Base width Open: 43" Closed: 26" Base height Weight capacity: LF2020: 400 lbs. LF2090: 600 lbs. Rear locking caster size 4" diameter (Clearance): 6" Overall base length Front caster size 4" diameter 50" Lifting height range Lifting mechanism 24 DC actuator Note: As measured from sling hooks.
LIMITED WARRANTY NOTE: The warranty below has been drafted to comply with the Federal Law applicable to products manufactured after July 4, 1975.This warranty is extended only to the original purchaser/consumer or dealer/non-consumer who does not buy for resale and to no other purchaser or transferee. GF Health Products, Inc.
THE FOREGOING WARRANTY IS EXCLUSIVE AND IN LIEU OF ALL OTHER EXPRESSED WARRANTIES AND IMPLIED WARRANTIES, INCLUDING BUT NOT LIMITED TO THE IMPLIED WARRANTIES OF MERCHANTABILITY AND FITNESS FOR A PARTICULAR PURPOSE, AND SHALL NOT EXTEND BEYOND THE DURATION OF THE EXPRESSED WARRANTY PROVIDED HEREIN, AND THE REMEDY FOR VIOLATIONS OF ANY IMPLIED WARRANTY SHALL BE LIMITED TO THE REPAIR OR REPLACEMENT OF THE DEFECTIVE PRODUCT OR PART PURSUANT TO THE TERMS CONTAINED HEREIN. 18 GF HEALTH PRODUCTS, INC.
NOTES LF2020/LF2090 Sit-To-Stand Patient Lift Owner’s Manual 19
U.S.A.
