Stove User Manual

ManualsBrandsLucent Technologies ManualsStoveMPB-33

HOMEOWNER'S CARE AND

OPERATION INSTRUCTIONS

OTL Report No. 116-F-36-5

B-VENT

MPB-33/35/40/45 SERIES

MODELS

A French manual is available upon request. Order P/N 875,031CF

Ce manuel d’installation est disponible en francais, simplement en

faire la demande. Numéro de la pièce 875,031CF.

Millivolt Models

P/N 875,031M REV. B 05/2006

B-VENT GAS FIREPLACES

MPB3328CNM

MPB3328CPM

MPB3530CNM

MPB3530CPM

MPB4035CNM

MPB4540CNM

MPB3328CNE

MPB3530CNE

MPB4035CNE

MPB4540CNE

Electronic Models

RETAIN THESE INSTRUCTIONS

FOR FUTURE REFERENCE

FOR YOUR SAFETY: Do not store or use gasoline

or other ﬂ ammables or liquids in the vicinity of

this or any other appliance.

FOR YOUR SAFETY: What to do if you smell gas:

• DO NOT light any appliance.

• DO NOT touch any electrical switches.

• Do not use any phone in your building.

• Immediately call your gas supplier from a

neighbor’s phone. Follow your gas suppliers

instructions.

• If your gas supplier cannot be reached, call

the ﬁ re department.

Installation and service must be performed by

a qualiﬁ ed installer, service agency or the gas

supplier.

WARNING: IF THE INFORMATION IN THIS MANUAL

IS NOT FOLLOWED EXACTLY, A FIRE OR EXPLO-

SION MAY RESULT CAUSING PROPERTY DAMAGE,

PERSONAL INJURY OR LOSS OF LIFE.

WARNINGS

•

Hot! Do not touch! The glass and

surfaces of this appliance will be hot

during operation and will retain heat

for a while after shutting off the appli-

ance. Severe burns may result.

•

Carefully supervise children in the

same room as appliance.

•

If small children are present in the home, it is

recommended that this appliance be ﬁ tted with

a screen door or screen panel kit. See Pages

18 & 19 for ordering information.

POUR VOTRE SÉCURITÉ: Ne pas entreposer ni

utiliser d'essence ni d'autre vapeurs ou liquides

inﬂ ammables dans le voisinage de cet appareil ou

de tout autre appareil.

POUR VOTRE SÉCURITÉ: Que faire si vous sentez

une odeur de gaz:

• Ne pas tenter d'allumer d'appareil.

• Ne touchez à aucun interrupteur. Ne pas vous

servir des téléphones se trouvant dans le bati-

ment où vous vous trouvez.

• Evacuez la piéce, le bâtiment ou la zone.

• Appelez immédiatement votre fournisseur de

gaz depuis un voisin. Suivez les instructions

du fournisseur.

• Si vous ne pouvez rejoindre le fournisseur de

gaz, appelez le service dos incendies.

L'installation et service doit être exécuté par un

qualiﬁ é installeur, agence de service ou le fournis-

seur de gaz.

AVERTISSEMENT: ASSUREZ-VOUS DE BIEN

SUIVRE LES INSTRUCTIONS DONNÉ DANS CETTE

NOTICE POUR RÉDUIRE AU MINIMUM LE RISQUE

D'INCENDIE OU POUR ÉVITER TOUT DOMMAGE

MATÉRIEL, TOUTE BLESSURE OU LA MORT.

Summary of content (28 pages)

PAGE 1
HOMEOWNER'S CARE AND OPERATION INSTRUCTIONS RETAIN THESE INSTRUCTIONS FOR FUTURE REFERENCE WARNINGS • Hot! Do not touch! The glass and surfaces of this appliance will be hot during operation and will retain heat for a while after shutting off the appliance. Severe burns may result. • Carefully supervise children in the same room as appliance. • If small children are present in the home, it is recommended that this appliance be fitted with a screen door or screen panel kit.
PAGE 2
SAFETY & WARNIING INFORMATION IMPORTANT: PLEASE READ THIS MANUAL IN ITS ENTIRETY AND UNDERSTAND THESE RULES TO FOLLOW FOR SAFETY. WARNING If the information in this manual is not followed exactly, a fire or explosion may result causing property damage, personal injury or loss of life. WARNING Children and adults should be alerted to the hazards of high surface temperatures. Use caution around the appliance to avoid burns or clothing ignition.
PAGE 3
CONGRATULATIONS! In selecting this Lennox B-Vent Gas Appliance you have chosen the finest and most dependable fireplace to be found anywhere. A beautiful, prestigious, alternative to a wood burning fireplace. Welcome to a Family of tens of thousands of satisfied Lennox Fireplace Owners. Please read and carefully follow all of the instructions found in this manual. Please pay special attention to the safety instructions provided in this manual.
PAGE 4
If your millivolt appliance is equipped with an optional remote wall switch or remote control kit and the pilot is lit, the appliance main burner may be turned on and off with the wall switch or remote control. The appliance must be isolated from the gas supply piping system (by closing its individual manual shut-off valve) during any pressure testing of the gas supply piping system at test pressures equal to or less than 1/2 psig (3.5 kPa).
PAGE 5
Variable Flame Height Adjustment If the securing screw has not been removed and you have reason to believe that you have a complete outside air system, contact your distributor to have your appliance inspected for the presence of the complete system. DO NOT assume that you have this system in place.
PAGE 6
WARNING Do not operate the shutoff lever unless a complete outside combustion air system has been installed with your appliance. To open the outside air shutter, open the bottom control access panel, reach into control compartment and pull the combustion air control lever all the way out. The outside air shutter should be fully open when the fireplace is in use and completely closed when the fireplace is not being used. Closing it when not in use will prevent outside cold air from entering the dwelling.
PAGE 7
MAINTENANCE SCHEDULE - Annually (Before the onset of the Burning Season) MAINTENANCE TASK Inspecting/Cleaning Burner, Logs ACCOMPLISHING PERSON Qualified Service Technician and Controls PROCEDURE Inspect valve and ensure it is properly operating. Check piping for leaks. Vacuum the control compartment, fireplace logs and burner area.
PAGE 8
Wire Termianls Cabinet Corner Back Of Limit Switch Door Frame Detail A Lintel Securing Screw Fire Box Top Hole in Cabinet Top Scoop Scoop Securing Screws Detail B Fire Box Top Lintel Securing-Screw Hole in Cabinet Top Limit/Bracket Securing Screws Limit Detail C Blocked Flue Safety Limit Location Inside View of Firebox Top/Right Side Intersection Figure 5 Refer to the maintenance schedule for maintenance tasks, procedures, periodicity and by whom they should be performed.
PAGE 9
Burner Adjustments SIT Millivolt Appliance Checkout Electronic Appliance Checkout Note - The air shutter for the burner primary air opening is factory-set. Do not adjust the factory-set position. The factory-set position is shown in Figure 7. The pilot flame should be steady, not lifting or floating. Flame should be blue in color with traces of orange at the outer edge. To light the burner, refer to the lighting instructions on Pages20 and 21. Ensure the igniter lights the pilot.
PAGE 10
Log Placement WARNING Logs get very hot and will remain hot up to one hour after gas supply is turned off. Handle only when logs are cool. Turn off all electricity to the appliance before you install grate and logs. WARNING This appliance is not meant to burn wood. Any attempt to do so could cause irreparable damage to your appliance and prove hazardous to your safety.
PAGE 11
Glowing Embers, Vermiculite, Decorative Volcanic Stone And Log Placement Instructions: Glowing Embers Step 1. Separate the Glowing Embers (Rockwool) into pieces about the size of a quarter (see Figure 13). Keep the pieces fluffed up, not matted. MPB-3328 & MPB-3530 Models Distribute these pieces over the burner as shown in Figure 14. Do not use more than is shown. The glowing embers should not be placed directly over the large burner slots as shown in Figure 14.
PAGE 12
MPB-3328 LOG PLACEMENT LOG SET Catalog Number 24M15 1 * Item 3 2 Description (stamped #) 1 Log, Rear (39-12) 2 Log, Left (39-1) 3 Log, Right (39-2) 4 Log, Top Center (39-13) 5 Log, Top/Left (39-3) 6 Log, Top/Right (39-4) * Item numbers above correspond to photos 4 5 1 6 Position the individual logs as shown below. Logs should be placed in the order shown. Position the rear log on the brackets at the rear of the firebox with the log's notches directly over the brackets.
PAGE 13
MPB-3530 LOG PLACEMENT LOG SET Catalog Number 24M22 1 * Item 3 2 Description (stamped #) 1 Log, Rear (39-5) 2 Log, Left (39-1) 3 Log, Right (39-2) 4 Log, Top Center (39-6) 5 Log, Top/Left (39-3) 6 Log, Top/Right (39-4) * Item numbers above correspond to photos 4 6 5 Position the individual logs as shown below. Logs should be placed in the order shown. Position the rear log on the brackets at the rear of the firebox with the log's notches directly over the brackets.
PAGE 14
MPB-4035 & MPB-4540 LOG PLACEMENT LOG SET Catalog Number 24M2501 1 * Item 2 3 Description (stamped #) 1 Log, Center (39-8) 2 Log, Rear (138) 3 Log, Right (39-10) 4 Log, Left (39-9) 5 Log, Top/Left (39-11) 6 Log, Top/Right (39-11) * Item numbers above correspond to photos 4 5 Position the individual logs as shown below. Logs should be placed in the order shown. Position the center log on the burner first, then place the glowing embers as shown in Figure 15.
PAGE 15
WIRING DIAGRAMS Wiring diagrams are provided here for reference purposes only. This information is also provided on schematics attached directly to the appliance on a pullout panel located within the control compartment. CAUTION: LABEL ALL WIRES PRIOR TO DISCONNECTION WHEN SERVICING CONTROLS. WIRING ERRORS CAN CAUSE IMPROPER AND DANGEROUS APPLIANCE OPERATION. Electronic Wiring Diagram (Honeywell) Showing the Blower Wiring for the Optional FBK-250 Kits 1.
PAGE 16
ACCESSORY COMPONENTS Decorative Firebox Accessories (all models) Cat. No. Remote Control Kit, Standard Cat. No. Model No. H0249 RCL Model No. 88L53 FGE 80L42 FDVS Description Bag of Glowing Embers (1 oz. rockwool) Bag of Decorative Volcanic Stone Description Remote Control System (Standard) Standard Remote Control System The Model RCL (Standard) Remote Control System, features a simple On/Off control function for the fireplace.
PAGE 17
ACCESSORY COMPONENTS 2-PIECE LOUVER SET KITS Polished Brass Arch Door Kit - Polished Brass Cat. No. Model Models-Where Used 98L05 ADK33CPB MPB-3328 26M43 ADK35CMPB MPB-3530 81L35 ADK40CPB MPB-4035 81L36 ADK45CPB MPB-4540 Cat. No. Model Models-Where Used 98L62 ADK33CBS MPB-3328 26M44 ADK35CMBS MPB-3530 98L69 ADK40CBS MPB-4035 98L70 ADK45CBS MPB-4540 Models Where Used Cat. # Model Cat.
PAGE 18
ACCESSORY COMPONENTS ARCH DESIGN SCREEN DOOR KITS Cat. No. Model SQUARE DESIGN SCREEN DOOR KITS Description Cat. No. Where Used Model Description H0858 AD35C 35” Arch Doors, Charcoal H0946 SD35C 35” Sq. Doors, Charcoal H0859 AD35TI 35” Arch Doors, Textured Iron H0947 SD35TI 35” Sq. Doors, Textured Iron H0860 AD35SP 35” Arch Doors, Satin Pewter H0948 SD35SP 35” Sq. Doors, Satin Pewter H0861 AD35AB 35” Arch Doors, Antique Brass H0949 SD35AB 35” Sq.
PAGE 19
Sunrise Style (upper grille shown) Crescent Style (lower grille shown) Decorative Arch Screen Panel Kit This easy to install optional screen installs over the standard glass enclosure panel to prevent direct contact with the hot glass surface. These screen panels cannot be used in conjunction with the arch door kits or door frame kits. Decorative Arch Screen Panel Kit Cat. No. Model Model Cat. No.
PAGE 20
LIGHTING INSTRUCTIONS – SIT MILLIVOLT GAS VALVE FOR YOUR SAFETY READ BEFORE LIGHTING WARNING: IF YOU DO NOT FOLLOW THESE INSTRUCTIONS EXACTLY, A FIRE OR EXPLOSION MAY RESULT CAUSING PROPERTY DAMAGE, PERSONAL INJURY OR LOSS OF LIFE. A. This appliance has a pilot which must be lighted with a piezo igniter. When lighting the pilot, follow these instructions exactly. B. BEFORE OPERATING smell all around the appliance area for gas.
PAGE 21
INSTRUCTIONS D’ALLUMAGE – VANNE GAZ MILLIVOLT SIT POUR VOTRE SÉCURITÉ, LISEZ CES INSTRUCTIONS AVANT L’ALLUMAGE AVERTISSEMENT : SI VOUS NE SUIVEZ PAS CES INSTRUCTIONS À LA LETTRE, IL POURRAIT S’EN SUIVRE UN INCENDIE OU UNE EXPLOSION CAUSANT DES DOMMAGES MATÉRIELS, DES BLESSURES CORPORELLES OU MÊME DES PERTES DE VIE. A. Cet appareil est muni d’une veilleuse qui doit être allumée avec un allumeur piézo-électrique. Lorsque vous allumez la veilleuse, suivre exactement ces instructions. B.
PAGE 22
LIGHTING INSTRUCTIONS — ELECTRONIC FOR YOUR SAFETY READ BEFORE LIGHTING WARNING: IF YOU DO NOT FOLLOW THESE INSTRUCTIONS EXACTLY, A FIRE OR EXPLOSION MAY RESULT CAUSING PROPERTY DAMAGE, PERSONAL INJURY OR LOSS OF LIFE. A. When lighting the appliance, follow these instructions exactly. B. BEFORE OPERATING smell all around the appliance area for gas. Be sure to smell next to the floor because some gas is heavier than air and will settle on the floor.
PAGE 23
INSTRUCTIONS D’ALLUMAGE — ELECTRONIC POUR VOTRE SÉCURITÉ, LISEZ CES INSTRUCTIONS AVANT L’ALLUMAGE AVERTISSEMENT: SI VOUS NE SUIVEZ PAS CES INSTRUCTIONS À LA LETTRE, IL POURRAIT S’EN SUIVRE UN INCENDIE OU UNE EXPLOSION CAUSANT DES DOMMAGES MATÉRIELS, DES BLESSURES CORPORELLES OU MÊME DES PERTES DE VIE. A. Lorsque vous allumez l’appareil, suivez exactement ces instructions. B.
PAGE 24
TROUBLESHOOTING Note: Before troubleshooting the gas control system, Ensure external gas shut off valve, located at gas supply inlet, (and wall switch, iff applicable), is in the “ON” position. Important: Valve system troubleshooting should only be accomplished by a qualified service technician. TROUBLESHOOTING GUIDE - MILLIVOLT GAS CONTROL SYSTEM SYMPTOM POSSIBLE CAUSES CORRECTIVE ACTION A. Defective igniter (no spark at electrode).
PAGE 25
TROUBLESHOOTING PROCEDURE - ELECTRONIC IGNITION SYSTEM START CHECK • Turn Off Gas Supply. • Ensure Valve Switch Is In ON Position. • Disconnect Control Harness. • Turn On Optional Remote Switch (if applicable) • Check for proper voltage at control harness (see insert A). Voltage NO should be 24V between 2 remote switch or pressure switch and 24V common and 24V hot.
PAGE 26
REPLACEMENT PARTS LIST Item # MPB-3328 Description Part No. MPB-3530 Qty. Part No. H3895 MPB-4035 Qty. Part No. 1 H3896 MPB-4540 Qty. Part No. Qty.
PAGE 27
REPLACEMENT PARTS 9 1 40/45 8 2 9 33/35 12 11 13 14 10 40/45 21 20 10 33/35 14 15 7 Located Inside Located Inside (see Figure 8) 5 (see Figure on Page 8) 26 40 6 23 27 24 15 44 41 25 22 5 3 43 42 4 NOTE: DIAGRAMS & ILLUSTRATIONS ARE NOT TO SCALE.
PAGE 28
Lennox Hearth Products reserves the right to make changes at any time, without notice, in design, materials, specifications, prices and also to discontinue colors, styles and products. Consult your local distributor for fireplace code information. Printed in U.S.A. © 2005 by LENNOX HEARTH PRODUCTS P/N 875,031M REV.