Technical Specifications
Revision: Oct 25, 2012
Supersedes: Oct 24, 2012
Ref. #: 458594,458579
Loctite® UCAN SEAL
TM
Page 2 of 3
Tools Typically Required:
Masking tape and tooling device.
Safety Precautions:
Apply and cure in a well ventilated area. Wear gloves and wash hands after use.
Preparation:
Apply sealant between 40°F (5°C) and 100°F (38°C). Surfaces must be clean, dry and free of old caulk, grease, dust and other contaminants.
Remove mold or mildew using bleach and detergent that does not contain ammonia. Rinse surface and allow to dry. For neat bead lines, mask
both sides of the joint.
To operate the dispenser first remove the black tear away tab. Remove the red plastic cap from the nozzle. Slide the red tab to the right to open
the nozzle and release the red trigger. Press on the trigger to dispense product. Adjust the bead side by sliding the red tab to the right to
increase or to the left to reduce the bead width. The nozzle can be rotated 180° for easier application.
Application:
Apply sealant with steady pressure, forcing the sealant into the joint. Smooth bead immediately with a wet finger or a tool. Remove masking
tape immediately after tooling and wipe excess off of hands and tools. Sealant is paintable within 2 hours depending on temperature and
humidity. Allow at least 24 hours before exposing to water. Periodically clean cured sealant with non-abrasive cleaner for best appearance.
Rinse well after cleaning. Note: The clear product will extrude white and will turn clear as it dries. After use, replace the red cap tightly on the
nozzle and slide the red tab fully to the left to seal the container for future use.
Clean-up
Clean tools and sealant residue immediately with warm water and soap. Cured sealant may be carefully cut away with a sharp-edged tool.
DAMAGED BY FREEZING. To maximize shelf life, store cartridge in a cool, dry place at temperatures above 40°F (5°C) and below 100°F
(38°C). Take unwanted product to an approved household hazardous waste transfer facility. Hardened material may be disposed of with trash.
Clear:
White:
Refer to Material Safety Data Sheet (MSDS) for further information.
The information and recommendations contained herein are based on our research and are believed to be accurate, but no warranty, express
or implied, is made or should be inferred. Purchasers should test the products to determine acceptable quality and suitability for their own
intended use. Nothing contained herein shall be construed to imply the nonexistence of any relevant patents or to constitute a permission,
inducement or recommendation to practice any invention covered by any patent, without authority from the owner of the patent.
DIRECTIONS
DISCLAIMER
PRECAUTIONS
STORAGE & DISPOSAL
CAUTION! Contents under pressure. Do not remove rubber plug. Contains ethylene glycol and crystalline
silica. May cause skin, eye and respiratory irritation. Do not puncture or incinerate container. Exposure to
heat or sunlight may cause container to burst. Do not expose to heat or store at temperatures above
120°F. Avoid eye and skin contact. Use with adequate ventilation. Do not swallow. FIRST AID: If
swallowed do not induce vomiting; call a physician or Poison Control center. For eye contact flush with
water for 15 minutes. For skin contact wash thoroughly with soap and water. If overcome by vapors, get
fresh air. KEEP OUT OF THE REACH OF CHILDREN. WARNING: This product contains a chemical
known to the State of California to cause cancer.
CAUTION! Contents under pressure. Do not remove rubber plug. May irritate eyes and skin. Do not
puncture or incinerate container. Exposure to heat or sunlight may cause container to burst. Do not
expose to heat or store at temperatures above 120°F. Avoid eye and skin contact. Do not swallow. FIRST
AID: If swallowed do not induce vomiting; call a physician or Poison Control center. For eye contact flush
with water for 15 minutes. For skin contact wash thoroughly with soap and water. KEEP OUT OF THE
REACH OF CHILDREN. WARNING: This product contains a chemical known to the State of California to
cause cancer.