SDS

IDH number: 1381191
Product name: Loctite® Naval Jelly® Rust Dissolver
Page 3 of 7
7. HANDLING AND STORAGE
Handling:
Use only with adequate ventilation. Prevent contact with eyes, skin and
clothing. Do not breathe vapor and mist. Wash thoroughly after handling.
Keep container closed. Refer to Section 8.
Storage:
Keep from freezing. Keep container tightly closed and in a cool, well-ventilated
place away from incompatible materials.
For information on product shelf life contact Henkel Customer Service at [phone].
8. EXPOSURE CONTROLS / PERSONAL PROTECTION
Employers should complete an assessment of all workplaces to determine the need for, and selection of, proper exposure
controls and protective equipment for each task performed.
Hazardous Component(s)
ACGIH TLV
OSHA PEL
AIHA WEEL
OTHER
Phosphoric acid
3 mg/m3 STEL
1 mg/m3 TWA
1 mg/m3 PEL
None
None
2-Propanol
200 ppm TWA
400 ppm STEL
400 ppm (980
mg/m3) PEL
None
None
Xanthan gum
None
None
None
None
Sulfuric acid
0.2 mg/m3 TWA
Thoracic fraction.
1 mg/m3 PEL
None
None
Silica, amorphous, fumed, crystal-free
10 mg/m3 TWA
Inhalable dust.
3 mg/m3 TWA
Respirable fraction.
20 MPPCF TWA
0.8 mg/m3 TWA
None
None
Diiron trioxide
5 mg/m3 TWA
Respirable fraction.
10 mg/m3 PEL Fume.
None
None
Magnesium oxide
10 mg/m3 TWA
Inhalable fraction.
15 mg/m3 PEL Total
particulate.
None
None
Aluminium oxide
1 mg/m3 TWA
Respirable fraction.
5 mg/m3 PEL
Respirable fraction.
15 mg/m3 PEL Total
dust.
None
None
Alcohols, C11-14-iso-, C13 rich, EO~
None
None
None
None
Engineering controls:
Provide adequate local exhaust ventilation to maintain worker exposure below
exposure limits.
Respiratory protection:
Use a NIOSH approved air-purifying respirator if the potential to exceed
established exposure limits exists.
Eye/face protection:
Safety goggles or safety glasses with side shields. Full face protection should
be used if the potential for splashing or spraying of product exists. Safety
showers and eye wash stations should be available.
Skin protection:
Use chemical resistant, impermeable clothing including gloves and either an
apron or body suit to prevent skin contact.
9. PHYSICAL AND CHEMICAL PROPERTIES
Physical state:
Gel
Color:
Pink
Odor:
Lime
Odor threshold:
Not available.
pH:
1.5 - 2.5
Vapor pressure:
Not available.
Boiling point/range:
212 °F (100°C) None Approximately
Melting point/ range:
Not applicable
Specific gravity:
1.191
Vapor density:
Not available.
Flash point:
Not determinable.