Owners Manual Assembly Instructions TURKEY FRYER KIT Models: LCTFKESB30 + LCTFKESB36 WARNING READ INSTRUCTION MANUAL BEFORE ATTEMPTING TO ASSEMBLE OR OPERATE THIS PRODUCT. Adult assembly required. Keep screws and parts out of reach of children. KEEP THIS MANUAL FOR FUTURE REFERENCE.
This instruction manual contains important information necessary for the proper assembly and safe use of the appliance. Read and follow all warnings and instructions before assembling and using the appliance. Follow all warnings and instructions when using the appliance. Keep this manual for future reference. SAFETY SYMBOLS Basic safety precautions should always be observed when using this appliance. Read and understand the meaning of these symbols before assembling and using this appliance.
TABLE OF CONTENTS Warnings 2, 4-6 Parts Diagram and Parts List 7 Hardware 8 Assembly Instructions 8-10 Operating and Cooking Instructions 11-14 Care and Maintenance 15-16 Troubleshooting 17 Warranty Information 18 lococookers.
WARNINGS SAVE THESE INSTRUCTIONS • The installation must conform with local codes or, in absence of local codes, with the National Fuel Gas Code, ANSI Z223.1/NFPA 54, Storage and Handling of Liquefied Petroleum Gases, ANSI/NFPA 58; or Natural Gas and Propane Installation Code, CSA B149.1; Propane Storage and Handling, CSA B149.2. • Never operate this appliance on or under any apartment or condominium balcony or deck. • This appliance is for outdoor use only.
WARNINGS LCTFKESB36: Cooking pot capacity = 36 quarts (34.07 liters). Diameter = 13.25” (33.66 cm). Height = 14.88” (37.80 cm) • Never overfill the cooking pot with oil, grease or water. Follow instructions in this manual for establishing proper oil, grease or water levels. • Introduction of water or ice from any source into the oil/grease may cause overflow and sever burns from hot oil and water splatter.
WARNINGS: LP TANK DANGER 1. Do not store a spare LP gas cylinder under or near this appliance. 2. NEVER fill the cylinder beyond 80% full. 3. If the instructions in 1 and 2 are not followed exactly, a fire causing serious injury or death may occur. 4. The safety release valve on the LP tank could activate the leaking of gas and cause a severe fire and increase the risk of serious injury or death. 5.
PARTS DIAGRAM NOTE: Wash all parts that will come into contact with food with warm soapy water. Rinse and towel dry.
ASSEMBLY INSTRUCTIONS Tools required: Phillips head screwdriver • Adjustable wrench (Not included) Assembly Hardware 8 B M5x30 Screw A M5x10 Screw 4 A 1 5 A x4 A 7 2 NOTE: Electrode and sensor wires not pictured for clarity of illustration. Remove factory zip ties from wires during assembly and before lighting burner. CAUTION: Make sure valve orifice fits inside of burner tube. A x4 NOTE: Remove hex nut from sensor and attach to tab on burner.
ASSEMBLY INSTRUCTIONS 3 B B B x4 Remove wing nut from bottom of burner. 8 Wing Nut 4 9 5 2 3 12 Remove wing nut and one washer from poultry stand hook. Install base, then washer and wing nut. lococookers.
ASSEMBLY INSTRUCTIONS 6 7 10 11 1 Lid-Assist Hook 4 13 14 10
OPERATING INSTRUCTIONS CONNECTING REGULATOR TO LP TANK: 1. Place LP tank on a secure, level and stable surface. 2. Turn control knob to the OFF position. 3. Turn LP tank OFF by turning hand wheel clockwise to a full stop. 4. Remove the protective cap from LP tank. Always use cap and strap supplied with valve. DO NOT use a POL transport plug. It will defeat the safety feature of the valve. 5. Hold regulator, insert nipple into LP tank valve.
OPERATING INSTRUCTIONS REGULATOR HOSE ASSEMBLY CHECK: Clean and inspect the hose before each use of the appliance. If there is evidence of abrasion, wear, cuts or leaks the hose must be replaced prior to the appliance being put into operation. The replacement hose assembly must be the one specified by the manufacturer. INSTRUCTIONS FOR LIGHTING BURNER: 1. Read all instructions before lighting. Only light burner outdoors. 2.
COOKING INSTRUCTIONS DISCONNECTING REGULATOR FROM LP TANK: 1. Turn regulator control valve counterclockwise to the OFF position. 2. Turn LP tank OFF by turning hand wheel clockwise to a full stop. When cooking, place the turkey turkey in the Twist & DrainTM basket with the head down and legs up. If using the poultry stand, place the turkey legs down and head up. Head down/Legs up Legs down/Head up Twist & DrainTM Basket Poultry Stand 3. Turn the coupling nut counterclockwise to loosen the connector.
COOKING INSTRUCTIONS DEEP FRIED WHOLE TURKEY STEP 1: Place cooking pot with oil on fryer stand. Make sure the oil thermometer is clipped to the side of the cooking pot. WARNING The oil thermometer should not be inserted into or touching food when measuring temperature of cooking oil. End of oil thermometer should be at least one inch below oil level. Do not use the lid when heating or cooking with oil. Heat the oil to 325ºF-350ºF (163ºC-177ºC). Never leave the heating oil unattend as it can ignite.
CARE AND MAINTENANCE PROPER CARE AND MAINTENANCE WILL KEEP YOUR APPLIANCE OPERATING SMOOTHLY CAUTION • Allow fryer to fully cool to 115ºF (46ºC) before performing any cleaning. • Keep the appliance area clear and free from combustible materials, gasoline and other flammable vapors and liquids. • Do not obstruct the flow of combustion and ventilation air. • Visually check the burner flames. BURNER FLAME CHECK Light the burner and adjust the flame with the regulator control valve.
CARE AND MAINTENANCE DANGER NEVER insert any tool or foreign object into the valve outlet or safety relief valve. You may damage the valve or cause a leak which can lead to explosion, fire, personal injury or death. WARNING NEVER mix oil and water in this appliance. Make sure the inside of the cooking pot is completely dry before adding any liquids. CAUTION Check burner and venturi tube for insects and insect nests. A clogged tube can obstruct gas flow and can result in a fire beneath the appliance.
TROUBLESHOOTING PROBLEM Burner will not light. SOLUTION Make sure the regulator coupling nut is fully tightened on the LP tank valve. Refill LP tank at an authorized dealer or purchase new filled LP tank. Ignition button was not pushed Press and hold the ignition button for and held. 30 seconds while lighting burner. Battery not installed correctly. Make sure the + and – ends of the battery are oriented properly. The + end should be toward the battery cap. Weak or dead battery.
WARRANTY INFORMATION The appliance has been manufactured under the highest standards of quality and workmanship. We warrant to the original consumer/purchaser that all aspects of this product will be free of defects in material and workmanship for one (1) year from the date of purchase. A replacement for any defective part will be supplied free of charge for installation by the consumer. Requests for expedited shipments of warranted parts will be at the consumer’s/purchaser’s expense.
