GC160 HONDA 9170-03-01 EX170 SUBARU 91270-03-01 MAN 4166180 Rev.
CALIFORNIA WARNING Proposition 65 Warning Diesel engine exhaust and some of its constituents are known to the State of California to cause cancer, birth defects and other reproductive harm. The engine exhaust from this product contains chemicals known to the State of California to cause cancer, birth defects or other reproductive harm.
LITTLE WONDER BLOWER IMPORTANT MESSAGE On behalf of everyone at Little Wonder, we would like to thank you for your purchase of a Little Wonder Gasoline Powered Optimax Blower. This professional blower was designed to the highest standards to ensure you many hours of uninterrupted service. This manual provides the information necessary for safe and efficient operation and service. For your safety, it is critically important that you read and understand this entire manual before operating your blower.
LITTLE WONDER BLOWER SAFETY This symbol means: NOTICE !!! Unauthorized modifications may present extreme safety hazards to operators and bystanders and could also result in product damage. Schiller Grounds Care, Inc. strongly warns against, rejects and disclaims any modifications, add-on accessories or product alterations that are not designed, developed, tested and approved by Schiller Grounds Care, Inc. Engineering Department. Any Schiller Grounds Care, Inc.
LITTLE WONDER BLOWER SAFETY MACHINE PREPARATION Operator preparation and training Read the Operation & Safety Manual – If an operator or mechanic cannot read English, it is the owner's responsibility to explain this material to them. If any portion of this material is unclear, contact your factory representative for clarification. – SITE PREPARATION AND CIRCUMSTANCES – Evaluate the terrain to determine how to safely perform the job. Only use accessories and attachments approved by the manufacturer.
LITTLE WONDER BLOWER OPERATING SAFELY IN GENERAL – Use extra care when loading or unloading the machine into a trailer or truck. – Do not run the engine in an enclosed area where dangerous carbon monoxide fumes can collect. – Never leave a running machine unattended. Always stop engine when leaving the operator position. – Do not blow towards people, cars, windows, or other items which could be injured or damaged by the blown debris. – Keep hands away from the blower air intake and outlet.
LITTLE WONDER BLOWER MAINTENANCE SAFETY In general - - Maintain machine according to manufacturer's schedule and instructions for maximum safety and best results. - Park machine on level ground. - Never allow untrained personnel to service machine. - Guards should only be removed by a qualified technician for maintenance or service. - Adjust or repair only after the engine has been stopped and the fan has stopped moving. - Disconnect spark plug wire(s) before doing any maintenance.
LITTLE WONDER BLOWER SAFETY SAFETY DECALS An important part of the safety system incorporated in this blower are the warning labels found on the blower. Replace labels if damaged or illegible. WARNING ADVERTENCIA Antes de comenzar: BEFORE STARTING: -Read and understand Operator manual and labels. -Wear hearing and eye protection. -Replace labels and Operator manual if lost or damaged. -Lea y entienda el manual del operador y las etiquetas.
SET-UP INSTRUCTIONS LITTLE WONDER BLOWER SET-UP INSTRUCTIONS 1. Open box. Remove upper handle and cardboard insert. 2. Lay box down with blower housing up. Use lower handle to roll unit out of the box. 3. Locate hardware package. 4. Install upper handle to lower handle with (4) 3/8-16 x 1-3/4 carriage bolts and (4) 3/8-16 flanged nylon insert nuts from the hardware package. Tighten the nuts securely but not so much as to crush the tube. (Figure 1) 5.
CONTROLS LITTLE WONDER BLOWER (BLOWER SHOWN WITH HONDA GC160 ENGINE. OTHER ENGINES ARE SIMILAR.) SWITCH (A)-SUBARU ONLY (not shown) Move to the “OFF” position to stop the engine. Move to the “ON” position before starting engine. THROTTLE (B) Controls engine speed and the amount of air being blown. 91270-03-01 model has an engine mounted throttle control. CHOKE (C) Move to the “CHOKE” position to apply the choke. Move to the “RUN” position to remove the choke.
LITTLE WONDER BLOWER OPERATION / MAINTENANCE BEFORE STARTING THE ENGINE 1. Read the Operator Manual and Engine Manual. Become familiar with the controls, how each functions, and what it operates. 2. Check the engine oil level and add if necessary. 3 Fill the fuel tank with good quality, clean, unleaded regular gasoline (petrol). Use a funnel to avoid spilling. OPERATING INSTRUCTIONS Air flow can be directed to the side or front by the two-position vertical deflector.
LITTLE WONDER BLOWER STORAGE / TORQUE SPECIFICATIONS STORAGE details. To prevent possible explosion or ignition of vaporized fuel, do not store equipment with fuel in tank or carburetor in an enclosure with open flame (for example, a furnace or water heater pilot). Before the equipment is put into storage for any period exceeding 30 days. 1. Drain all fuel from the fuel tank and fuel lines. 2. Start the engine and run until all the fuel is used from the carburetor float bowl and the engine stops.
LITTLE WONDER BLOWER INTAKE GUARD ASSY FIGURE 1 2 1 4 4 3 5 6 7 9 10 8 11 ITEM PART NO. 1 2 3 4 5 6 7 4166183 4165218.7 64123-54 64268-02 64229-02 4165926.10 64123-253 64123-254 8 4166730 4166729 9 10 64164-13 4163424 4165139 11 4165169 DESCRIPTION QTY LABEL-INTAKE GUARD ASSY-INTAKE GUARD BLT-HEX 5/16-18 X .
LITTLE WONDER BLOWER ENGINE ASSY FIGURE 2 5 10 8 7 8 19 21 16 3 15 6 19 4 16 11 19 17 16 20 1 18 12 2 20 13 12 14 11 1 9 ITEM 1 2 3 PART NO.
LITTLE WONDER BLOWER HOUSING ASSEMBLY FIGURE 3 27 28 3 2 18 5 21 29 9 20 1 15 19 4 20 16 17 13 14 23 12 8 22 11 7 ITEM PART NO. 8 26 6 DESCRIPTION 25 QTY 1 2 64141-6 4166329 NUT 5/16-18 S-HOUSING LG BLOWER (USED ON 91270 MODEL) 4166328 S-HOUSING SM BLOWER (USED ON 9160 & 9170 MODELS) 3 1 3 4 5 6 7 8 9 10* 4166187 4165975 910517 64151-31 910130 8-18 4165977 4166188 4166189 4166474 1 1 4 2 1 3 1 1 11 4166476.
5 YEAR LIMITED SERVICE & WARRANTY POLICY FOR GASOLINE POWERED MAXIMUM OUTPUT BLOWERS All Little Wonder Gasoline Powered Maximum Output blowers are guaranteed against defects in material and workmanship for a period of FIVE YEARS from date of purchase, when used for RESIDENTIAL SERVICE, or COMMERCIAL SERVICE. Any Little Wonder Gasoline powered Maximum Output Blower or part found to be defective within the warranty period is to be returned to any registered Little Wonder dealer.
