User Manual

Rev: 11.04.2014
Page 7
Level Up Troubleshooting Guide
LEVEL-UP
®
(TOWABLE) TROUBLESHOOTING GUIDE
Fig. 8
A
B
Hitch Recognition
1. Turn on Touchpad.
2. Press the left and right buttons simultaneously (Fig. 8A and 8B).
3. The front of the unit will raise to the height where the auto level sequence
was started.
NOTE: If the auto level sequence was started with the front of the unit in a below
level condition, the Hitch Recognition will not function and the LCD
will display “Feature Disabled”. In order for hitch recognition feature to
function, the auto level sequence MUST be started with the front of the
unit above level.
Reconnecting the Unit to a Tow Vehicle
1. Connect tow vehicle and make sure travel trailer and hitch are connected
and locked.
2. Push “UP” arrow until” AUTO RETRACT” appears in LCD screen.
3. Push “ENTER.” System will immediately retract all jacks.
Touch Pad Error Codes
NOTE: To clear Error Code, push "ENTER" - If error remains, the code will appear again.
Problem Probable Cause Corrective Action
"EXCESS ANGLE"
Unsecured controller.
Uneven or sloped site.
Check and secure controller placement.
Relocate the coach.
"BAD CALIBRATION" Unit zero point was not set correctly. Reset zero point (See LIP sheet 317)
"FEATURE DISABLED"
Front of coach below level when
starting Auto Level process.
Raise front of coach above level and restart Auto
Level process.
"LOW VOLTAGE"
Bad connection or wiring.
Discharged or bad battery.
Check wiring - repair or replace.
Test battery voltage under load - charge or
replace.
"OUT OF STROKE"
Unsecured controller.
Uneven or sloped site.
Check and secure controller placement.
Relocate the coach.
"EXTERNAL SENSOR" Bad connection or wiring.
Replace or repair connection to rear remote
sensor.
"JACK TIME OUT"
System could not level in expected
time.
Check for obstructions, leaks, fluid level and
voltage to pump motor under load.
"AUTO LEVEL FAILURE"
Unsecured controller.
Voltage drop.
Check and secure controller placement.
Test battery voltage under load - charge or
replace.
Retry.