G����� C������ 2.0 OWNER'S MANUAL Rev: 04.10.
TABLE OF CONTENTS System Basic Jack Operation Prior to Operation Dropping off unit Taking Up Strut Pin Slop (If J.T Strong Arm Stabilizers are installed ONLY) Reconnecting the unit to a tow vehicle Truck Hauler Operation (Manual ONLY) Zero setting the control Error display in LCD Preventative Maintenance Procedures Ground Control 2.0 4 Point Assembly Ground Control 2.0 6 Point Assembly Ground Control 2.0 Component List Ground Control 2.0 Component List Rev: 04.08.
System Failure to act in accordance with the following may result in death or serious injury. The use of the Ground Control 2.0 to support the unit for any reason other than that which it is intended is prohibited by Lippert's limited warranty. The Lippert Ground Control 2.0 is designed as a "leveling" system only and should not be used to provide service for any reason under the coach such as changing tires or servicing the leveling system. Lippert Components Inc.
Dropping off unit 1. Loosen J.T. Strong Arm Stabilizer “T” handles. (If applicable.) 2. Disconnect 5th Wheel latch. 3. Turn battery power “ON.” Fig. 1A Fig. 1B 4. Release the inner legs of both landing gear jacks by pulling on the quick release pins and extending the inner leg 4-5 inches. 5. Push touch panel “ON/OFF” (Fig. 2A) to turn system on. LCD Screen lights up (Fig.2B). Fig. 2 A C B 6. Push the DOWN ARROW to scroll to “DROP FRONT JACKS” option on LCD screen.
Taking Up Strut Pin Slop (If J.T Strong Arm Stabilizers are installed ONLY) 1. After leveling is complete, LCD screen will read “LEVEL SUCCESSFUL/CHECK STABILIZERS.” 2. Push “FRONT” button momentarily until front stabilizer pins are tight. 3. Push “REAR” button momentarily unit rear stabilizer pins are tight. 4. Push “ON/OFF” button to turn system off. Fig. 3 A Reconnecting the unit to a tow vehicle 1. Be sure main power switch “ON.” 2. Loosen J.T. Strong Arm Stabilizer “T” handles.
Truck Hauler Operation (Manual ONLY) 1. Loosen J.T. Strong Arm Stabilizer “T” handles. (If applicable.) 2. Turn the Touch Panel “ON.” LED lights up green. 3. Push “FRONT” button to extend FRONT jacks to gain height. 4. To retract jacks: A. Push “RETRACT” button; Orange LED lights up. B. Push the “FRONT” button to retract jacks and hook up vehicle. Once 5th wheel is coupled, push “FRONT” button and hold until jacks are fully retracted. C.
Error display in LCD 1. If an error occurs before or during operation, the error will be displayed in the LCD and a “buzzer “ will sound. 2. The errors that will be displayed are: A. “EXCESS ANGLE” - Unit is beyond 5° front to back or 3° side to side. Relocate unit on site. B. “BAD CALIBRATION” - Bad zero point. C. “FEATURE DISABLE” - Hitch Recognition feature inoperative. Operate system in manual mode. D. “LOW VOLTAGE” E. “OUT OF STROKE” - Relocate the unit. F.
GROUND CONTROL 2.0 4 POINT ASSEMBLY LEVELING AND STABILIZATION Mounting Bracket Motor Gearbox Rear Jack Landing Gear Power to Ground Harness Controller Rear Sensor Foot Pad Touchpad Front Landing Gear Harness Touchpad Harness Rear Jack Harness Rev: 04.10.
GROUND CONTROL 2.0 6 POINT ASSEMBLY LEVELING AND STABILIZATION Mounting Bracket Gearbox Landing Gear Motor Leveling Jack Leveling Jack Leveling Jack Harness Footpad Controller Rear Sensor Power to Ground Harness Rear Sensor Harness Touchpad Touchpad Harness Manual Override Rev: 04.10.
GROUND CONTROL 2.0 COMPONENT LIST LEVELING AND STABILIZATION A B C D F E H G I Callout A B C D E F G H I Rev: 04.10.
GROUND CONTROL 2.0 COMPONENT LIST LEVELING AND STABILIZATION J K L M N Callout J K L M N Rev: 04.10.
The contents of this manual are proprietary and copyright protected by Lippert Components, Inc. (“LCI”). LCI prohibits the copying or dissemination of portions of this manual unless prior written consent from an authorized LCI representative has been provided. Any unauthorized use shall void any applicable warranty. The information contained in this manual is subject to change without notice and at the sole discretion of LCI. Revised editions are available for free download from www.lci1.com.
