Instruction Manual

Page
the intercooler to 62 lb-in (7 Nm).
67. Fill the intercooler system with 50/50 Dex-
Cool according to the GM ll procedure.
Connect the battery and then run the car for
short while and check for leaks.
NOTE - if the pump sound level changes or
is erratic, you likely have air trapped in the
system and need to bleed the system and
make sure it is properly lled with coolant.
68. Install the front impact bar and tighten the
13 mm head bolts to 22 lb-ft (30 Nm)
69. Put on the front facia support and tighten the
19.
held in by the factory plastic retainer clip
while the bottom is again held in by the side
bolt from the intercooler.
66. Tighten down the side bolts and top bolts of