Owner's Manual

24
c.p. Allstar Corporation
Downingtown, PA 19335
This Gate Operator is built in the USA and
complies with all requirements of
Underwriters' Laboratories Standard UL-325.
P/N 107659 Rev. A, 7/97
PHYSICAL
PAD:
22” W x 29”D x 3”H Elevation
OVERHEAD CLEARANCE:
Minimum 4” Required
UNIT SIZE:
13”W x 15-3/8”D x 28-3/8” H
FRAME:
Welded, Uni-Body; Phosphatized And
Painted to UL Standards
COVER:
Welded, Phosphatized And Painted to
UL Standards. Key lock to prevent
unauthorized access
SHIPPING WEIGHT:
150 lbs.
PRIMARY VOLTAGE:
115 VAC, 60 Hz, Single Phase
ELECTRICAL SOURCE:
One 3-Wire, 15-Amp Service From
Breaker Panel Required Per Operator
CONTROL VOLTAGE:
12/24 VDC
RADIO RECEIVER POWER:
24 VAC, 20 mA
MOTOR:
1/2 HP, 4.4 Amp, PSC, Instant
Reversing, Thermally Protected (Manual
Reset)
AUTO TIMER-TO-CLOSE:
Built-In, Adjustable From 3-90 Seconds
ELECTRICAL
DRIVE
DRIVE SYSTEM:
Two-Stage; High Efficiency Timing
Belts and Pulleys
TOTAL SPEED REDUCTION:
22.5:1
OUTPUT SHAFT:
1” dia., Ball-Bearing Mounted
DRIVE MECHANISM:
22-Tooth Sprocket; #41 Roller Chain,
#50 Chain Optional
LIMITS:
Independent Open & Close;
Displaced Cam With Micro-Switch
Contacts; Adjustable Without Tools
OPERATOR LOCK:
Electro-Mechanical, DC Solenoid;
Key Release (Standard). Drop Out
Lock Option (releases if power is
interrupted)
MAX. GATE WEIGHT:
1575 lbs., Level Grade (Standard)
MAX. GATE WIDTH:
45 ft. (Standard)
MAX. CYCLES PER HOUR:
60 Open/Close Per Hour; 1200 Open/
Close Per Day (All Calculations
Based On Typical 25’ Gate On Level
Grade for Standard Operators)
GATE SPEED:
13 inches/second
CAPACITIES
Specifications subject to change without notice. Consult the factory.
Manufacturer’s Limited Warranty
Allstar warrants its gate operators to be free from defect in material and workmanship for a period of five (5) years from the date of purchase
for single family home use and three (3) years from the date of purchase for multi-family and commercial use. This warranty covers all
components except the electronic circuit boards which are warranted for three (3) years from the date of purchase for single family home use
and two (2) years from the date of purchase for multi-family and commercial use. To obtain service contact your dealer.
To obtain service under this warranty the buyer must obtain authorization instructions for the return of any goods from Allstar before
returning the goods. The goods must be returned with complete identification, with copy of proof-of-purchase, freight prepaid and in
accordance with Allstar’s instructions or they will not be accepted. In no event will Allstar be responsible for goods returned without proper
authorization or identification.
Goods returned to Allstar for warranty repair within the warranty period, which upon receipt by Allstar are confirmed to be defective and
covered by this limited warranty, will be repaired or replaced at Allstar’s sole option, at no cost and returned pre-paid. Defective parts will
be repaired or replaced with new or factory rebuilt parts at Allstar’s sole option.
This limited warranty does not cover non-defect damage, damage caused by unreasonable use, damage caused by improper installation or
care, vandalism or lightning, fire or excessive heat, flood or other acts of God (including, but not limited to misuse, abuse or alterations,
failure to provide reasonable and necessary maintenance), labor charges for dismantling or reinstalling a repaired or replaced unit, or
replacement batteries.
These warranties are in lieu of all other warranties, either expressed or implied. All implied warranties of merchantability and/or fitness for a
particular purpose are hereby disclaimed and excluded. Under no circumstances shall Allstar be liable for consequential, incidental or
special damages arising in connection with the use or inability to use this product. In no event shall Allstar’s liability for breach of warranty,
breach of contract, negligence or strict liability exceed the cost of the product covered hereby. No person is authorized to assume for Allstar
any other liability in connection with the sale of this product.
This warranty gives you specific legal rights. You may also have other rights which vary from state to state. Warranty effective after May
15th, 1997.
For Information:
Phone [phone] FAX [phone]
TECHNICAL SPECIFICATIONS