PowerSwitch Enclosed Disconnect Switch with Receptacle (EDSR) Cat. No. EDSR Rated: 30A-600VAC Max. Mechanically Interlocked Switch with Receptacle (MIDSR) Cat. No. MIDSR Rated: 30A-600VAC Max.
EDSR and MIDSR Enclosed Disconnect Switch with Receptacle (Figure 4) and Mechanically Interlocked Disconnect Switch with Receptacle (Figure 5) NOTE: Receptacle sold separately. • For use with 20A -30A NEMA Locking Receptacles and any mating NEMA 20A-30A Locking Plug. • he EDSR and the MIDSR have an environmental rating of IP66, UL Standard 50 and NEMA T environmental ratings of 4X and 12K, when in use with Leviton WETGUARDTM locking plugs.
FEATURES • Meets the requirements of Outdoor/Indoor installations conforming to IP 54 and 3R with cover closed (when not in use). • Meets the requirements of Outdoor/Indoor installations, conforming to IP 66, UL Standard 50, and NEMA Environmental Ratings of 4X,12K, only when used in conjunction with Leviton WetguardTM plugs. • For use with 20A - 30A NEMA locking plugs. • Provides ON-OFF switched control for a connected load.
TO INSTALL: NOTE: Leviton EDSR and MIDSR Switches may be mounted for Top or Bottom feed of supply wires (refer to Figures 2 and 3). Mounting: Warning: To avoid fire, shock, or death; turn off power at the circuit breaker or fuse, and test that the power is off before attempting to install enclosure. CAUTION: ThESE enclosureS must always be mounted vertically with receptacle end down. Note: Hinged cover will open only when the rotary switch knob is turned to the “OFF” position. 1.
Top or Bottom Feed: NOTE: A metal closure plug must be grounded (bonded) back to an unused ground terminal. Use of a UL Listed Watertight conduit fitting (not included) required to maintain Type 4X and Type 12K ratings (refer to Figures 2, 3). 1. When using Top feed conduit entrance, always form condensation drip loops in wiring as shown in Figure 2.
Figure 4 EDSR Front View Figure 5 MIDSR Front View Affix Receptacle Voltage Label Here Affix Receptacle Voltage Label Here Affix IP66 Ratings Label Here Affix IP66 Ratings Label Here Switch Knob Switch Knob Receptacle Cover Receptacle Cover Interlock Handle 20A RECEPTACLE SEAL INSTALLATION (Figure 6) OTE: 20A Receptacle seal components are only to be used when a 20A Receptacle is N installed. If installing a 30A Receptacle no components are required to be replaced.
Figure 6 Wetguard™ Accessory Seal Replacement Environmental Rating Label EDSR MIDSR Rubber Gasket (20A) “V” Ribs *Gasket Clamp (20A) “V” Ribs Mounting Screws (4) Gasket-Clamp Assembly Mounting Screws (4) Gasket-Clamp Assembly * 30A Rubber Gasket and Gasket Clamp are pre-installed with EDSR and MIDSR. EDSR DEVICE OPERATION To use, turn EDSR switch to the OFF position. Raise Receptacle Cover and insert mating plug. Refer to Ratings chart (page 7) for the list of mating configurations.
Ratings HP NEMA Amps Wiring Voltage, AC CONFIG Rating Receptacle Type** Cat. No. Plug Type** Cat. No.
Wiring Diagrams Wire Diagram 1 NEMA L5-20 G N Wire Diagram 2 NEMA L6-20 G L1 L2 L3 N W X G G Wire Diagram 5 NEMA L9-20 N Y N T1 T2 T3 Y Wire Diagram 9 NEMA L21-20 N L1 L2 L3 W G N T1 T2 T3 X G G Wire Diagram 7 NEMA L15-20 G L1 L2 L3 N L1 L2 L3 Y Wire Diagram 8 NEMA L16-20 G L1 L2 L3 T1 T2 T3 N L1 L2 L3 T1 T2 T3 X W X Y X Y G Y G Z G Z Wire Diagram 10 NEMA L22-20 G N Wire Diagram 11 NEMA L23-20 G L1 L2 L3 Y X Z W G N L1 L2 L3 T1 T2 T3 T1 T2 T3 T
Wiring Diagrams Wire Diagram 12 NEMA L5-30 G N Wire Diagram 13 NEMA L6-30 G L1 L2 L3 N W X G G Wire Diagram 16 NEMA L9-30 N Wire Diagram 17 NEMA L14-30 G L1 L2 L3 N Y Wire Diagram 20 NEMA L17-30 N N T1 T2 T3 X G G Wire Diagram 18 NEMA L15-30 G L1 L2 L3 N L1 L2 L3 Y Wire Diagram 19 NEMA L16-30 G L1 L2 L3 N T1 T2 T3 L1 L2 L3 T1 T2 T3 X W X Y X Y G Y G Z G Z Wire Diagram 21 NEMA L21-30 G L1 L2 L3 G L1 L2 L3 W T1 T2 T3 X G N Wire Diagram 15 NEMA L8-30 T1
NOTES
LIMITED 2 YEAR WARRANTY AND EXCLUSIONS Leviton warrants to the original consumer purchaser and not for the benefit of anyone else that this product at the time of its sale by Leviton is free of defects in materials and workmanship under normal and proper use for two years from the purchase date.
