BREW EXPRESS ™ Operation GUIDE model no. For more information see our instructional video online at wwww.BrewExpress.com.
Cont en ts 1. Safety 1 2. Features 3 3. Controller Functions 4 4. Start Up 5 5. Operation 6. Maintenance 6 -7 8 7. Troubleshooting 9 - 11 8. Parts & Service 12 9. Frequently Asked Questions 10.
Safety Safety IMPORTANT SAFEGUARDS When using electrical appliances, basic safety precautions should always be followed, including the following: IMPORTANT: Please read and follow instructions carefully before starting your BREW EXPRESS™ in-the-wall COFFEE SYSTEM. 1. Read all Instructions. 2. Do not touch hot surfaces. Use handles or knobs. 3. The voltage and frequency of the supply connections should conform to those of the rating label. 4.
Features Controller Functions Display Panel AM/PM Indicator Indicates AM or PM for clock. Clock Continuously displays current time and is used for setting automatic brew time. Convenient and practical. Brew Express™ is plumbed into the wall and fills on command so you never have to manually fill with water. Handsome Euro design compliments any decor. Auto Indicator Light Light is on when waiting for automatic brew cycle to start. Patented in-the-wall design saves precious counter space.
Start Up Operation IMPORTANT: Please read and follow instructions carefully before starting your BREW EXPRESS™ in-the-wall COFFEE SYSTEM. Carafe Brew Basket Did you purge water lines during installation to remove any foreign particles (debris) in lines? Debris in water lines can clog brewer system causing failure, and VOID ALL WARRANTIES. Single Cup Brew Basket 1. Set Clock Time advances when hour/minute buttons are held down, note AM/PM indicator. The BREW EXPRESS™ dispenses extremely hot water.
Operation maintenance 5. Manual Brew Cycle To manually start a brew cycle move the slide switch from OFF to ON. If the switch is already in the ON position, switch it to the OFF position and then back to ON. The brew light will turn on once the cycle has started. If brewer is cold, the heater will preheat the water before starting the brew cycle. After the selected amount of water is dispensed, the brew light will remain on for 40 seconds. At that time the BREW EXPRESS™ will beep five times.
Troubleshooting Troubleshooting Display is not illuminated Water overflow from brew basket • Ensure the power to the rough-in box is turned on (check circuit breaker). • • Ensure brewer is fully pressed into the rough-in box. • Ensure the outlet inside the rough-in box is properly wired. Remove the brewer and check outlet with volt meter. If power is on and no voltage is detected at the outlet, wiring is incorrect. Turn off power.
Parts & Service Troubleshooting Carafe or Mug not detected (flashing brew light) • • • • IRD cannot detect flat black or clear glass mug (change mug color) IRD window is dirty (wipe with moist towel and dry) Mug not close enough to IRD (move farther into brewer) IRD is not set properly, call for technical service.
frequently asked questions frequently asked questions What type of coffee filter do I use? How long will the coffee stay hot in the carafe? For Standard size Brew Basket: Flat 10 to 12 cup filter (recommended brand Bunn or Brew Rite) *Please Note: A 8-12 cup filter will not work properly because the sides of the filter are not high enough to hold all the coffee grounds appropriately. Between 2 - 3 hours (based upon Full Carafe volume); it is a thermal vacuum sealed carafe (no glass).
frequently asked questions Water Pressure: What is minimum and maximum water pressure? The Brew Express specifications require a minimum of 30 psi to a maximum of 90 psi. If it is lower than 30 psi, it is possible the pressure sensor will not allow the Brew Express to work. You will get an “EEEE” message. This can mean no water; low pressure, kinked water line or your water filter is plugged. In some installations the brewer may run fine if it is the only appliance using water.
www.brewexpress.com Printed in CHINA.
