User guide



OPERATINGINSTRUCTIONS:ICB-12



Connecttheinstrumenttoagroundedmainsoutlet,afterensuringthattheVoltageisthesameasstatedonthenameplate.

Theinstrumentmustbeconnectedtoanearthed(grounded)supply.

SecuretheInstrumenttotheBathusingthefixingbow.

Useonlydistilledorsoftwater,toavoidbuild-upofscaleontheheatingelement.Donotuseinflammableliquids.

Theminimalwaterlevelmustbeabout3cmabovetheholesnearthepumphousing.

Thetwospringclampsareintendedforfixingofareferencethermometer.

Switchtheinstrumenton,andadjusttherequiredtemperaturebyturningtheknob,ifthereisadeviation,betweenthe

temperaturesofthebathandtheknob(afterthetemperatureinthebathhassettled),adjusttheknobaccordingly.

Whentheheatingelementisinaction,theredpilotlamplightsinaccordancewiththeswitchingofthethermostat..

Theflowcanbereducedbyaclamppressingaplasticorrubberhosefastenedonthejetnozzle.

Thecirculationpumpallowsalsothecirculationoftemperaturecontrolledwatertoinstrumentsoutsidethebaths.Inthese

instancesitisimperativethatthewaterisreturnedtothebath,preferablyinthevicinityoftheheatingelement.

SAFETYModel,theICB-12isequippedwithanadditionalsafetyCut-Off,preventingelementburn-out,ifthewaterlevelfalls.

Toresetpushthebrownbuttonontherearoftheinstrument.

Theinstrumentsdonotrequireanymaintenance,excepttheperiodicremovalofscaleonthepumpandheatingelement.The

pumphousingcaneasilybecleanedbyremovingthethreescrewsatthebottomofthepumphousing.Afterremovingthe

instrumentfromwater,thepumpshouldbeplaceddownwards(toavoidwaterpenetration).



SPECIFICATION

Temperaturerange:Slightlyaboveambientupto+1000CAwithexternalcooling,thiscanbeextendedtoupto1000G.

Accuracy:approx.10.500at37°C(dependingonoperatingconditions).

Voltage:220V,50Hz(or115V,50/60Hz),1000W

LaboratoryEquipmentPtyLtdInstructionManual-ImmersionThermostatPage4