Install Manual Part 1

ManualsBrandsL-3 Communications, Avionics Systems ManualsElectronicsSkyWatch Traffic Advisory System

SKY497

Installation Manual

iii

Rev. C

TABLE OF CONTENTS

Paragraph Page

Chapter 1

GENERAL INFORMATION

1.1 INTRODUCTION ............................................................................................................ 1-1

1.2 FUNCTIONAL DESCRIPTION ..................................................................................... 1-1

1.3 PHYSICAL DESCRIPTION............................................................................................ 1-2

1.3.1 TRC497 Transmitter Receiver Computer P/N 805-10800-xxx...................................... 1-3

1.3.2 Display.............................................................................................................................. 1-7

1.3.3 NY164 Directional Antenna P/N 805-10890-001........................................................... 1-9

1.4 SPECIFICATIONS ........................................................................................................ 1-11

1.4.1 WX-1000/SKY497 Display............................................................................................. 1-11

1.4.2 Transmitter Receiver Computer (TRC)........................................................................ 1-12

1.4.3 Directional Antenna ...................................................................................................... 1-13

1.5 INTERFACE .................................................................................................................. 1-13

1.6 EQUIPMENT REQUIRED NOT SUPPLIED.............................................................. 1-13

1.7 INSTALLATION APPROVAL ...................................................................................... 1-14

1.8 WARRANTY INFORMATION...................................................................................... 1-15

1.8.1 Warranty Statement...................................................................................................... 1-15

1.8.2 Related Policies and Procedures................................................................................... 1-15

Chapter 2

INSTALLATION

2.1 INTRODUCTION ............................................................................................................ 2-1

2.2 UNPACKING, INSPECTION AND STORAGE ............................................................ 2-1

2.3 ANTENNA LOCATION .................................................................................................. 2-1

2.4 TRC LOCATION.............................................................................................................. 2-2

2.5 DISPLAY LOCATION................................................................................................... 2-11

2.6 CABLE REQUIREMENTS AND FABRICATION ...................................................... 2-11

2.6.1 Antenna Cables.............................................................................................................. 2-12

2.6.2 Configuration Jumpers ................................................................................................. 2-14

2.6.3 Display Cable ................................................................................................................. 2-15

2.6.4 Heading Input Cable ..................................................................................................... 2-18

2.6.5 ARINC 429 Data Cables................................................................................................ 2-20

2.6.6 Altimeter Input Cable ................................................................................................... 2-21

2.6.7 Audio Alert Output Cable ............................................................................................. 2-21

2.6.8 Suppression Bus I/O...................................................................................................... 2-21

2.6.9 Ground Proximity Warning System (GPWS) Input .................................................... 2-22

2.6.10 SKYWATCH® /Stormscope® Display Mode Switch.................................................... 2-22

2.6.11 WX-1000 Maintenance Switch...................................................................................... 2-22

2.6.12 Squat Switch Input........................................................................................................2-22

2.6.13 Landing Gear Switch Input .......................................................................................... 2-23

2.6.14 Power Cable ................................................................................................................... 2-23

2.7 ANTENNA INSTALLATION........................................................................................ 2-23

2.8 TRC MOUNTING TRAY INSTALLATION ................................................................. 2-25

2.9 TRC INSTALLATION ................................................................................................... 2-26

2.10 MOUNTING THE WX-1000/SKY497 DISPLAY ......................................................... 2-28

2.10.1 Panel Cutout .................................................................................................................. 2-28

2.10.2 Display Installation ....................................................................................................... 2-29