Instruction Manual

ManualsBrandsKontron ManualsHardwareCP6005X-SA

D R A F T — F O R I N T E R N A L U S E O N L Y

The pulse of innovation

» User Guide «

CP6005(X)-SA

Doc. ID: 1055-2501, Rev. 1.0

Date: December 20, 2013

Summary of content (24 pages)

PAGE 1
DRAFT — FOR INTERNAL USE ONLY » User Guide « CP6005(X)-SA Doc. ID: 1055-2501, Rev. 1.
PAGE 2
User Guide CP6005(X)-SA Revision Histor y 1.0 Brief Description of Changes Initial issue Date of Issue 20-Dec-2013 Impr int Kontron Europe GmbH may be contacted via the following: MAILING ADDRESS TELEPHONE AND E-MAIL Kontron Europe GmbH Sudetenstraße 7 D - 87600 Kaufbeuren Germany +49 (0) 800-SALESKONTRON sales@kontron.com For further information concerning other Kontron products, please visit our Internet website: www.kontron.com. Disclaimer Copyright © 2013 Kontron AG. All rights reserved.
PAGE 3
User Guide CP6005(X)-SA Contents Revision History .......................................................................................................... 2 Imprint ..................................................................................................................... 2 Contents .................................................................................................................... 3 Tables .........................................................................................
PAGE 4
User Guide 2.7.1.2 2.7.1.3 2.7.2 2.7.3 2.7.4 2.7.5 2.7.5.1 2.7.6 2.7.7 2.7.8 2.7.9 2.7.9.1 2.7.9.2 2.7.9.3 2.7.9.4 2.7.9.5 2.7.9.6 2.7.9.7 2.7.9.8 2.7.9.9 2.7.9.10 2.7.10 2.7.10.1 2.7.10.2 2.7.10.3 2.7.10.4 2.7.11 IPMI LEDs and HS LED .................................................................................. 29 General Purpose LEDs .................................................................................. 29 USB Interfaces ...................................................................
PAGE 5
User Guide 4.1.1 4.1.2 4.1.3 4.2.1 4.2.2 4.2.3 4.2.4 4.2.5 Start-Up Requirement .................................................................................. 54 Power-Up Sequence..................................................................................... 54 Regulation ................................................................................................ 55 Power Consumption of the CP6005(X)-SA Accessories ..........................................
PAGE 6
User Guide 9.2.5 9.3 9.3.1 9.3.1.1 9.3.1.2 9.3.2 9.4 9.4.1 9.4.2 9.4.3 9.4.3.1 9.4.3.2 9.4.3.3 9.5 9.5.1 9.5.1.1 9.5.1.2 9.5.1.3 9.5.1.4 9.5.2 9.5.2.1 9.5.2.2 9.5.2.3 Exit Setup Menu ......................................................................................... 73 The uEFI Shell ............................................................................................ 74 Introduction, Basic Operation .......................................................................
PAGE 7
User Guide CP6005(X)-SA 1 2 3 4 5 6 7 8 9 10 11 12 13 14 15 16 22 24 27 28 29 30 31 32 33 34 35 36 37 38 39 40 41 42 43 44 45 46 47 48 49 50 51 52 53 CP6005(X)-SA Main Specifications ......................................................................... 18 Standards ........................................................................................................ 23 Additional Standards for Boards Ordered with Ruggedized Service ................................. 23 Related Publications ..........
PAGE 8
User Guide 54 55 56 57 58 59 60 61 Navigation ....................................................................................................... 70 Main Setup Menu Sub-Screens and Functions ............................................................ 71 Advanced Setup Menu Sub-Screens and Functions ..................................................... 72 Security Setup Menu Functions .............................................................................. 72 TPM Configuration Sub-Screen .......
PAGE 9
User Guide CP6005(X)-SA 1 2 3 4 5 6 7 8 9 10 11 12 13 14 CP6005(X)-SA Functional Block Diagram ................................................................ 4 HP CP6005(X)-SA Front Panel ............................................................................ 4 HP CP6005-SA Board Layout (Top View) ............................................................... 4 HP CP6005X-SA Board Layout (Top View) ..............................................................
PAGE 10
User Guide CP6005(X)-SA Warranty Within the warranty period, the repair of products is free of charge as long as warranty conditions are observed. The warranty does not apply to defects resulting from improper or inadequate maintenance or handling by the buyer, unauthorized modification or misuse, operation outside of the product’s environmental specifications or improper installation or maintenance.
PAGE 11
User Guide CP6005(X)-SA 1 Introduction B o a r d O ve r v i ew The CP6005(X)-SA is a highly integrated 6U CompactPCI® processor board based on the 4th generation Intel® Core™ i7/i5 processor in combination with the Intel® QM87 Chipset. The CP6005-SA is a fully-compliant PICMG 2.16 processor board whereas the CP6005X-SA offers additional dual 10 Gigabit Ethernet and PCI Express to the backplane.
PAGE 12
User Guide CP6005(X)-SA 1. 2 S y s te m E x p a n s i o n C a p a b i l i t i e s The CP6005(X)-SA has a 3.3 V, PMC mezzanine interface configurable for 32-bit / 66 MHz PCI operation. This interface supports a wide range of PMC modules with PCI interface including all of Kontron’s PMC modules and provides an easy and flexible way to configure the CP6005(X)-SA for various application requirements. For information on the PMC interface, refer to Chapter 2.7.7, "PMC Interface". 1.2.
PAGE 13
www.kontron.com IPMB I2C GPIO 3.3V IPMI FPGA Board Control GP EEP Temp. Sense (standard/ recovery) SPI Boot Flashes UART dual TPM COMA Front I/O SATA Cable Conn. VGA CRT VGA Switch RTC 4x SATA SMB SATA SMB SPI LPC Bat. HDA HDA VGA CRT VGA Switch RS232 Rear I/O VGA CRT COMA RJ-45 2.5" SATA HDD/SSD or SATA Flash Module LPC RST 4x USB 2.0 USB 2.0 Intel® QM87 PCH USB 2.
PAGE 14
User Guide CP6005(X)-SA 1.3.
PAGE 15
User Guide CP6005(X)-SA 1.3.3 Board Layout Figure 3: 4 HP CP6005-SA Board Layout (Top View) Battery J12 GbE E Intel® I350 Magnetics J5 MMADPSATA01 Module J11 GbE B DRAFT — FOR INTERNAL USE ONLY HDD/SSD Magnetics SATA Flash Module J15 J10 GbE A Intel® QM87 J16 IPMI/WD/TH LEDs J14 GP/POST CODE LEDs J19 J17 J20 J21 J3 J18 PMC/XMC J2 4th Gen. Intel® Core™ i7/i5 J9 J8 J7 J1 J6 HS LED J13 www.kontron.
PAGE 16
User Guide CP6005(X)-SA Figure 4: 4 HP CP6005X-SA Board Layout (Top View) Battery J12 GbE E Intel® I350 Magnetics J5 MMADPSATA01 Module J11 GbE B DRAFT — FOR INTERNAL USE ONLY HDD/SSD Magnetics SATA Flash Module J15 J10 GbE A Intel® QM87 Intel® 82599ES J16 J41 10GbE Controller IPMI/WD/TH LEDs J14 GP/POST CODE LEDs J4 J19 J17 J20 J21 J3 J18 PMC/XMC J2 4th Gen. Intel® Core™ i7/i5 J9 J8 J7 J1 J6 HS LED J13 www.kontron.
PAGE 17
User Guide CP6005(X)-SA DRAFT — FOR INTERNAL USE ONLY Figure 5: 4 HP CP6005(X)-SA Board Layout (Bottom View) 4 3 2 1 SW1 ON 4 3 2 1 SW2 ON J25 www.kontron.
PAGE 18
User Guide CP6005(X)-SA 1. 4 Te ch n i c a l S p e c i f ic a t i o n Table 1: CP6005(X)-SA Main Specifications FEATURES SPECIFICATIONS The CP6005(X)-SA supports the following 4 th generation processors: » Quad-core Intel® Core™ i7-4860EQ (SV), 1.8 GHz, 6 MB L3 cache, GT3e, Intel® Iris™ Pro Graphics 5200 » Quad-core Intel® Core™ i7-4700EQ (SV), 2.4 GHz, 6 MB L3 cache, GT2, Intel® HD Graphics 4600 » Dual-core Intel® Core™ i5-4400E (SV), 2.
PAGE 19
User Guide CP6005(X)-SA Table 1: CP6005(X)-SA Main Specifications (Continued) SPECIFICATIONS High-Speed Serial Rear The following interfaces are provided on the rear I/O via two ZDplus high-speed I/O Interconnection connectors, J4 and J41 (PICMG 2.20): (CP6005X-SA) » Two 10GBASE-KR interfaces » One x4 PCI Express 2.
PAGE 20
User Guide CP6005(X)-SA SPECIFICATIONS Onboard Connectors » One XMC connector, J19 (P15) » Two SATA connectors » One 7-pin, standard SATA connector, J14 » One 34-pin, SATA extension connector, J16 » One JTAG connector, J15 » One XDP-SFF (debug) connector, J25 » Four CompactPCI connectors J1, J2, J3 and J5 » Two ZDplus high-speed serial rear I/O connectors, J4 and J41 (PICMG 2.
PAGE 21
User Guide CP6005(X)-SA Table 1: CP6005(X)-SA Main Specifications (Continued) FEATURES » Temperature sensors integrated in the 4 th gen.
PAGE 22
User Guide CP6005(X)-SA Table 1: CP6005(X)-SA Main Specifications (Continued) SPECIFICATIONS Power Consumption See Chapter 4 for details. Temperature Range Operational: Storage: General Batter y 0°C to +60°C Standard -40°C to +70°C Extended -40°C to +85°C Without hard disk and without batter y 3.
PAGE 23
User Guide CP6005(X)-SA 1. 5 St a n d a rd s This product complies with the requirements of the following standards. Table 2: Standards ASPECT CE STANDARD Emission EN55022, EN61000-6-3 Immission EN55024, EN61000-6-2 Electrical Safety EN60950-1 Mechanical Mechanical Dimensions IEEE 1101.
PAGE 24
User Guide CP6005(X)-SA 1. 6 Re l a te d Pu b l i c a t i o n s The following publications contain information relating to this product. Table 4: Related Publications CompactPCI Systems PUBLICATION PICMG 2.0, Rev. 3.0 CompactPCI Specif ication DRAFT — FOR INTERNAL USE ONLY PRODUCT PICMG 2.16, Rev. 1.0 CompactPCI Packet Switching Backplane Specif ication PICMG 2.20, Rev. 1.0 CompactPCI Packet Serial Mesh Backplane Specif ication PICMG 2.9, Rev. 1.0 CompactPCI System Management Specif ication PICMG 2.