Operator's Manual CRAFTSMAN 4-Cycle GAS TRIMMER Model No. 316.791961 INCREMENTALISM RSEUEVABCE STARTING EASE * SAFETY * ASSEMBLY * OPERATION + MAINTENANCE * PARTS LIST » LIFESPAN, P. 13 CAUTION: Before using this product, read this manual and follow all safety rules and operating instructions. Sears Brands Management Corporation, Hoffman Estates, IL 60179 U.S.A.
RULES FOR SAFE OPERATION CALIFORNIA PROPOSITION 65 WARNING WARNING A THE ENGINE EXHAUST FROM THIS PRODUCT CONTAINS CHEMICALS KNOWN TO THE STATE OF CALIFORNIA TO CAUSE CANCER, BIRTH DEFECTS OR OTHER REPRODUCTIVE HARM. TABLE OF CONTENTS Safety Rules Warranty Know Your Unit Assembly Instructions . . Cif and Fuel Information Starting/Stopping Instructions Operating Instructions Maintenance and Repair Instructions. Cleaning and Storage Optional Accessory . . Troubleshooting Chart Lo... ooh 0 SPECIALIZATIONS © +.
RULES FOR SAFE OPERATION Uses the Li nit only in daylight or good artificial light Avoid accidental starting. Be in the starting position whenever pulling the starter rope. Tha operator and Unit must be in a stable position while starting. See Starting/Stopping Instructions, Use the right tool. Only use this tool for the purpose intended Da not overreach, Always keep proper footing and balance Always hied tha unit with both hands when operating. Keep a firm grip on both the front and rear handle or gps.
WARRANTY STATEMENT CRAFTSMAN 2 YEAR FULL WARRANTY FOR 2 YEARS from the date of purchase, this product is warranted against any defects In material or workmanship. Defective product wit receive free repair of free replacement If repair is unavailable.
Cree Rg YE legs] td OIL AND FUEL INFORMATION ADJUSTING THE D-HANDLE 1 Loosen the screws on the Handiness (Fig. 2). 2. While holding the unit in the aerating position (Fig. 13). position the D-handier to the location that provides the best grip. 3, Tighten the clamp screws evenly, nth the D-handier is SECLUDE. Shaft Grip O-Handle Min Sin. (16.24 amp Screw Fig.
OIL AND FUEL INFORMATION The tse of fuse additives, such as STA-BULB Gas Stabilizer or an equivalent, will inhibit corrosion and minimize the formation of gum deposits. Using a fuse additive can keep fuel from forming harmful deposits in the carburetor for up to six (6) months.
OPERATING INSTRUCTIONS TIPS FOR BEST TRIMMING RESULTS © Keep the trimmer attachment parallel to the ground. « Trim only when grass and weeds are dry.
MAINTENANCE AND REPAIR INSTRUCTIONS NOTE: Use the bottle and split saved from initial Lie to measure the correct amount of oll The top of the label on the collie measures approximately 3.04 Loz. (©0 mi (Fig. 23). Che the level, Ses Checking 4 tho Off Level. If the level is low, add a sal i Fill Line amount of of and age rack, Do not overfill (Fig. 22). 5 Replace the ofl fill plug. rd AIR FILTER MAINTENANCE Fig.
MAINTENANCE AND REPAIR INSTRUCTIONS + Both rocker arms move freely. Exhaust Ocker Av and both valves are closed Adjusting Foster Iffiness Statements are not true, Gauge repeat slop 6. , 7. Side the foolery gauge Benson nos the rocker armament the Valve gre 0452 ma : rein spring. Measure the 5 clearance between the valve 4 stem and rocker aim (Fig. 53). eve Stem Measure both the intake and fia Etna loyalist valves, The recommended clearance for both intake and exhaust is L003 = 006 in. {076 ~ 0.152 mm).
TROUBLESHOOTING PROBLEM ENGINE WILL NOT START Therapy fuel dank Primer wasn't pressed enough Old fuel Fouled spark plug Cold weather start lever is in closed position ENGINE WILL NOT IDLE SOLUTION Fill fuel tank with fuel Press primer bulb Lully and slowly 10 tines Drain gas tank and add fresh fuel Replace or neap the spark plug Move cold weather start lever to open position Air filter fs plugged Old fuel improper idle speed ENGINE WILL NOT ACCELERATE Replace or clean the air filter Drain gas tank and add f
SPECIFICATIONS EGU TYPO «ov sou none ene AT-Cole, 4-Coyle Displacement . . Llc in £8 oe) Operating RPM 6,800+ rpm hide Speed RPM 2.800 3,600 rpm ignition Type. . Ironical ignition Switch Rocker Switch NAVE CIBAFAMCE LL LL iia eee aaa ae (LO DB-0L006G © mm} Spark Plug Gap 0.025 inch (0.635 mr) Spark Plug | Champion HAZARD or equivalent plug Lubrication Cee . Ce Cee FE SAE 30 Off Crankcase Ol Capacity i... BD4oz{eomi Fuel... Unleaded Carburetor . Diaphragm, All-Position Starter Auto Rewind Mutter .
INSTRUCCIONES DE ARRANQUE ¥ APAGADO INSTRUCCIONES DE MANTENIMIENTO Y REPARACIÓN 7. Oprima el control del regulador y deje que el motor se caliente durante NOTA: Para ver ta lista completa de términos y ta cobertura de los 30a 60 segundos. dispositivos de control motor no arana, regrese al paso 3. silenciador, carburador, etc, lea la declaración de Californiana El motor se para mientras oprime el regulador, regrese al paso 4. que viene junto oon la unidad.
INSTRUCCIONES DE MANTENIMIENTO ¥ REGIONARIO INSPECCIÓN DEL NIVEL DE ACEITE PRECAUCIÓN: Para evitar un desgaste excesivo del motor y of dacio de la Unidad. mantenga siempre ef nivel de afecte correcto en f cárter del encinal. No opere nunca fa unidad ton ef aceite debajo del extremo inferior de la varilla de medición. No podones exagerar la importancia de verificar y mantener ef nivel correcto de aceite en el cárter del encinal. Inspeccione el nivel de aceite antes de cada uso: 1.
PARTS LIST REPLACEMENT PARTS MODEL 316.
PARTS LIST REPLACEMENT PARTS MODEL 316.791961 4-CYCLE GAS TRIMMER lem Part No.
Your Home For troubleshooting, product manuals and expert advice: E @ manageability www.managemylife.com For repair — in your home ~ of all major brand appliances, lawn and garden equipment, or heating and cooling systems, no matter who made it, no matter who sold it! For the replacement parts, accessories and owner's manuals that you need to do-it-yourself. Lo For Sears professional installation of home appliances | and items like garage door openers and water heaters.
