OWNER’S MANUAL OUTDOOR GAS FIRE PIT (BATTERY,NG CONVERSION KIT NOT INCLUDED) FP-003T IMPORTANT，RETAIN FOR FUTURE REFERENCE:READ CAREFULLY FOR OUTDOOR USE ONLY.
SAFETY INFORMATION Please read and understand this entire manual before attempting to assemble, operate or install the product. This appliance has been tested to and complies with the ANSI Z21.97-2017, Outdoor Decorative Gas Appliances. When connecting to a fixed piping system, The installation must conform to local codes or the absence of local codes to the National Fuel Gas Code. ANSI Z223.1.NFPA 54; National Fuel Gas Code; National Gas and Propane Installation Code, CSA B149.
SAFETY INFORMATION WARNING DANGER DANGER indicates an imminently hazardous situation which, if not avoided, will result in death or serious injury. Failure to comply with the precautions and instructions provided DANGER with this fire pit can result in death, serious bodily injury and property loss or damage from hazards of fire, explosion, burn, asphyxiation, and/or carbon monoxide poisoning. Only persons who can understand and follow the instructions should use or service this fire pit.
SAFETY INFORMATION WARNING WARNING We cannot foresee every use which may be made of our fire pit. Check with your local fire safety authority if you have questions about fire pit use. Other standards govern the use of fuel gases and heat producing products for specific uses. Your local authorities can advise you about these. If no local codes exist, follow National Fuel Gas Code, ANSI Z223.1. In Canada, installation must conform to local codes.
OPERATION CHECKLIST Operation Checklist For a safe and pleasurable heating experience, perform this check before each use. Before Operating: 1. I am familiar with entire owner’s manual and understand all precautions noted. 2. All components are properly assembled, intact and operable. 3. No alterations have been made. 4. All gas connections are secure and do not leak. 5. Wind velocity is below 10 mph. 6. Unit will operate at reduced efficiency below 40°F/4.44°C 7.
EXPLODED VIEW 6
PART LIST PART NO. DESCRIPTION QTY A Lid 1 B Table top 1 C Table base left side panel 1 D Table base back panel 1 E Table base right side panel 1 F Beam 1 G Table frame 1 H Tank shelf 1 I Door 1 J Glass beads 5 kgs K Glass windshield 1 set L Rain Cover 1 SCREW PACKAGE PART NO.
ASSEMBLY INSTRUCTIONS Step 1 ⑥x2 ① ⑥ Step 2 ⑥x2 ① ⑥ 8
Step 3 ⑥x4 ① ⑥ Step 4 ③x2 ① ③ 9
Step 5 ③x2 ① ③ Step 6 ⑥x2 ① ⑥ 10
Step 7 ⑤x1 ①x1 ②x1 ① ①x1 ② ⑤x1 ⑤ Step 8 ④x6 ① ④ 11
Step 9 Step 10 ¡ Ì 12 ¡ Á
Step 11 Step 12 13
Step 13 Step 14 14
INSTALLING LP GAS TANK Connect LP Gas Tank Before connecting, be sure that there is no debris caught in the head of the LP gas tank, head of the regulator valve or in the head of the burner and burner ports. Connect regulator/hose assembly to tank by turning knob clockwise stops. LP GAS Disconnect LP Gas Tank Before disconnecting make sure the LP gas tank valve is "CLOSED". Disconnect regulator/hose assembly from LP gas tank by turning knob counterclockwise until it is loose.
LEAK TESTING WARNING: Before using this outdoor fire pit, make sure you have read, understand and are following all information provided in the Dangers and Warnings. Failure to follow those instructions can cause death ,serious injury or property damage. WARNING Never use your fire pit without leak testing all gas connections, hoses and propane tank. DANGER ♦ ♦ ♦ ♦ To prevent fire or explosion hazard: DO NOT smoke or permit ignition sources in the area while conducting a leak test.
BATTERY INSTALLATION 1xAAA Battery (Battery not included) Put correct Battery in before use.
Step2 Step3 18
LIGHTING INSTRUCTIONS Caution: Keep outdoor gas cooking appliance area clear and free from combustible materials, gasoline and other flammable vapors and liquids. Caution: Do not obstruct the flow of combustion and ventilation air. Caution: Check and clean burner/venturi tubes for insects and insect nests. A clogged tube can lead to a fire beneath the grill. Caution: Attempting to light the burner with the lid closed may cause an explosion. Lighting 1. Read instructions before lighting. 2.
TROUBLESHOOTING PROBLEM POSSIBLE CAUSE CORRECTIVE ACTION Propane cylinder is empty Replace propane cylinder Blockage in orifice Clear blockage Control knob is not in ON position Turn control knob to ON Gas pressure is low Turn cylinder valve OFF and fill the cylinder Outdoor temperature is less than 40ºF and tank is less than 1/4 full Use a full cylinder Control knob fully ON Check burner and orifices for blockage Carbon build-up Dirt or film on reflector and burner screen Clean reflector
CARE AND MAINTENANCE CAUTION: All cleaning and maintenance should be done when fire pit is cool and with the fuel supply disconnected. 1. DO NOT clean any outdoor fire pit part in a self cleaning oven. The extreme heat will damage the finish. 2. Do not enlarge valve orifices or burner ports when cleaning the valves or burners. Notices 1. This outdoor fire pit should be thoroughly cleaned and inspected on a regular basis. 2. Abrasive cleaners will damage this product. 3.
ASSEMBLY GLASS WINDSHIELD 22
