English portable propane fire pit Assembly Instructions and use and care Manual MODEL/serial # __________ IMPROPER INSTALLATION, ADJUSTMENT, ALTERATION, SERVICE, MAINTENANCE or use CAN CAUSE INJURY OR PROPERTY DAMAGE. READ THE INSTALLATION, OPERATING AND MAINTENANCE INSTRUCTIONS THOROUGHLY BEFORE INSTALLING OR SERVICING THE EQUIPMENT. Metal Fusion, Inc. 712 St. George Avenue. Jefferson, LA 70121 If you have any problems or questions Call Us Toll Free at 1-800-783-3885 7:30 A.M. to 3:30 P.M.
danger If you smell gas: 1. Shut off gas to the appliance. 2. Extinguish any open flame. 3. If odor continues, keep away from the appliance and immediately call your gas supplier or Fire Department. Do not store or use gasoline or other flammable vapors and liquids in the vicinity of this or any other appliance. An LP-cylinder not connected for use shall not be stored in the vicinity of this or any other appliance. For Outdoor Use Only.
Read and Understand before using this product Throughout this manual the words appliance, burner and fire pit will be used interchangeably to refer to the King Kooker® Outdoor Fire PIt. 1) This is an ATTENDED appliance. Do NOT leave this appliance unattended while the burner is lit. Monitor the appliance when hot after use. Heated equipment can remain at high temperatures which can cause burns long after operation. 2) Keep children, pets and unauthorized persons away from the appliance at all times.
14) In the event of rain, snow, hail, sleet or other forms of precipitation while in operation, turn off the appliance burners and gas supply. Do not attempt to move the appliance. Do not use this appliance if any part has been under water. Immediately call a qualified service technician to inspect the appliance and to replace any part of the control system and any gas control which has been under water. 15) See Use and Care section for LP Gas Cylinder Information.
Read and understand all instructions before using your king kooker® product table of contents Warnings. . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . 2-4 Table of Contents. . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . .
Metal Fusion, Inc. Limited One-Year Warranty What this warranty covers This warranty covers all components of this appliance to be free from defects in materials and workmanship, with the exceptions stated below. How long coverage lasts This warranty runs for one year from the date of purchase. Please keep your receipt with this manual for future reference. what is not covered This warranty does not cover the following: Incidental and Consequential Damages.
Owner’s Registration Dear Customer, Thank you for purchasing a King Kooker® Outdoor Fire Pit! Please take a moment to fill out your registration form and return it to us. We are always happy to hear suggestions and comments from our customers about our products. Completion of this registration allows us to contact you if the need arises. Please keep your receipt with your instruction manual. It will be necessary as a proof of purchase for us to help you if there is a problem with your appliance.
TAPE HERE FOLD ________________________ ________________________ ________________________ Place Stamp Here Metal Fusion, Inc. 712 St.
section I FIRE PIT assembly The use and care manual must be read and understood before using the appliance Throughout this manual the words appliance, burner and fire pit will be used interchangeably to refer to the King Kooker® Outdoor Fire PIt. TOOLS REQUIRED: TORQUE WRENCH or ADJUSTABLE WRENCH, LEAK TESTING SOLUTION 1. Before assembling, check that all components are included in the shipping carton. Accessories may vary according to model. Check the list of accessories on your box.
Brass Fitting with MANUAL VALVE ASSEMBLY INSTRUCTIONS Locate the brass fitting with manual valve (with hose/regulator attached). Tighten the brass fitting’s threaded end (with orifice) into the venturi with a torque wrench, up to a torque of 95 to 105 lb./in. Alternatively, hand tighten securely and then, using a wrench, tighten an additional 1-1 1/2 turns. The manual valve handle should be positioned upright when installed. See below for pictures of correct assembly.
SANDBAG FILLING INSTRUCTIONS Locate the sandbag provided with the appliance. Approximately 35 lbs. of sand (not included) is required to fill the sandbag. Follow the below steps to fill the sandbag with sand 1. Locate the opening of the sandbag and fill with sand to just below the first set of strings provided on the outside of the sandbag (approximately 1/3 the length of the sandbag.) 2. Loop the strings around the sandbag and pull and tie the strings tightly to seal off the first third of the sandbag. 3.
section II Use and care Throughout this manual the words appliance, burner and fire pit will be used interchangeably to refer to the King Kooker® Outdoor Fire PIt. Read and Understand before using this appliance LP gas cylinder information King Kooker® Fire Pits are manufactured for use with 20lb. (9 kg) LP Gas Cylinders. Important information to remember about LP Gas cylinders include: 1. Always read and follow the cylinder manufacturer’s instructions. 2.
Connection Instructions 1. Check that your manual valve is set to not allow gas flow. The manual valve should be 90 degrees to the line of gas flow. See below Figure 1. This is the OFF position. MANUAL VALVE (OFF POSITION) 2. Attach the regulator to the cylinder valve by turning the Type 1 fitting clockwise. Refer to the assembly diagram for the appliance below. TYPE 1 CONNECTION 20 LB. LP GAS CYLINDER 3.
placement instructions 1. For outdoor use only. 2. Never operate this appliance within 10 ft. (3.05m) of any structure, combustible material or other gas cylinder. Never operate this appliance within 25 ft. (7.5m) of any flammable liquids or vapors. 3. There must be no combustibles or roof overhead. 4. The appliance must be on a level, stable, noncombustible surface such as brick, concrete or dirt. Not suitable are surfaces such as wood, asphalt or plastic which may burn, blister or melt. 5. Keep 48” (1.
lighting and operating Instructions The appliance must not be lit until the preceding placement instructions have been completely followed. 1. 2. 3. 4. 5. Check the appliance to make sure that it is set up as per the diagram (Figure 1). Make certain the manual valve is turned to the “OFF” position (Figure 2). Open the cylinder control valve by turning it counterclockwise as per the diagram (Figure 3). Place a lit multipurpose lighter above the burner.
Turning off and storing the APPLIANCE after use Never Move the APPLIANCE while in use or still hot. 1. 2. 3. After each use turn OFF the fire pit at the manual valve first, then at the gas cylinder valve. Check to make sure there is no flame and all valves are off. Do not leave the appliance until it has cooled completely. Disconnect the regulator from the cylinder by turning the Type 1 fitting counterclockwise until the regulator is separated from the tank.
section Iii Read and understand all instructions before using your king kooker® product Frequently Asked Questions and Answers 1. My appliance’s flame appearance is very weak. Answer: If the hose assembly has a Type 1 Connection (black/green knob), it is equipped with a flow limiting device. This device is intended to limit the flow of gas should there be a leak between the regulator and the appliance.
NOTES 18
NOTES 19
SAFETY PRECAUTIONS Failure to follow these instructions and Warnings could result in fire, explosion, burn hazard or carbon monoxide poisoning which could cause Property Damage, Personal Injury or Death. Read and understand the entire Assembly Instructions and Use and Care Manual before using this product. If you lose your manual and need a replacement, or have questions, please contact us at 1-800-783-3885 between the hours of 7:30 A.M. and 3:30 P.M. CST Monday - Friday, or go to www.kingkooker.
