Instructions / Assembly

3
1) This is an ATTENDED appliance. The timer located on the hose/regulator is NOT a
replacement for proper monitoring. Do NOT leave this appliance unattended while
the burner is lit or while heating oil, grease, water, or cooking food.
2) DO monitor the oil temperature constantly using the thermometer provided with
the cooker. Monitor the appliance when hot after use [oil, grease or water above
100 ° F (38 ° C)]. Heated liquid and equipment can remain at scalding temperatures
long after cooking has ended.
3) NEVER overfill the cooking pot with oil, grease or water. Follow instructions in this
manual for establishing proper oil, grease or water levels.
4) DO NOT light or relight burner if the oil level is not filled to the “Minimum Fill Line
level mark on the cooking pot.
5) Keep children, pets and unauthorized persons away from the appliance at all
times.
6) The use of alcohol, prescription or non-prescription drugs may impair your ability
to properly assemble or safely operate this appliance. Do NOT assemble or
operate this appliance if using alcohol, prescription or non-prescription drugs.
7) This appliance is for OUTDOOR use only. Do NOT use in a building, garage, tent
or any other enclosed area. Do NOT use in or on a recreational vehicle or boat.
NEVER use this appliance as a heater.
8) Do not locate this appliance under ANY overhead construction. Keep a minimum
clearance of 10ft. (3.05m) from the sides, front and back of the appliance to ANY
construction. Keep the area clear of ANY combustible material. Do not use on or
under ANY apartment or condo balcony or deck.
9) When cooking, the fryer/boiler must be on a level, stable, noncombustible surface
such as brick, concrete or dirt. Not suitable are surfaces such as
wood, asphalt or plastic which may burn, blister or melt.
10) Check all cooker fittings for leaks before each use. Do not use a flame to check
for gas leaks. Keep the fuel supply hose away from any heated surfaces. Only the
LP hose/regulator and timer assembly specified by Metal Fusion, Inc. should be
used with this appliance.
11) When cooking with oil or grease, the thermometer provided MUST be used.
Follow instructions in this manual for proper installation and use of thermometer.
If the thermometer supplied with the fryer/boiler has been lost or damaged, a
replacement thermometer specified by Metal Fusion, Inc. shall be obtained before
using the appliance.
12) If the temperature of cooking oil exceeds 350 ° F (177 ° C) or if oil begins to smoke,
immediately turn the burner or gas supply OFF and wait for the temperature to
decrease to less than 350 ° F (177 ° C) before relighting burner according to the
instructions in this manual.
13) When cooking with oil/grease, have a Type BC or ABC fire extinguisher readily
available. In the event of an oil/grease fire, do not attempt to extinguish with water.
Immediately call the Fire Department. A Type BC or ABC fire extinguisher may, in
some circumstances, contain the fire.
READ AND UNDERSTAND BEFORE USING THIS PRODUCT
Throughout this manual the words appliance, cooker, fryer/boiler, burner and stove
will be used interchangeably to refer to the King Kooker
®
Outdoor Cooker.