Installation Guide

Lithium Manganese Battery – Bobbin type 1/13/2010 2/5
FDK ENERGY CO.,LTD.
Eyes contact :
Flush the eyes with plenty of water for at least 15 minutes
immediately, without rubbing. Take a medical treatment. If
appropriate procedures are not taken, this may cause an eye
irritation
Swallowing :
In case of swallowed battery, immediately refer for medical
attention.
5. Fire fighting
Extinguishing method :Since vapor, generated from burning batteries may make eyes, nose and throat
irritates, be sure to extinguish the fire on the wind word side. Wear the
respiratory protection equipment in some cases. The Lithium metal in batteries
reacts with water and generates Hydrogen gas. Risk of explosion by fire
fighting using water.
Fire extinguishing agent :Dry chemical, alcohol-resistant foam, carbon dioxide and dry sand are effective.
6. Spillage disposal
Chemical contents are contained in sealed can. But if the battery is mechanically or electrically abused,
the contents may leak out. In this case, wipe with a dry cloth. Take away from the fire.
7. Precautions for handling and storing
Handling :
When packing the batteries, do not allow battery terminals to
contact each other, or contact with other terminals. Be sure to pack
batteries by providing partitions in the packing box, or in a separate
plastic bag so that the single batteries are not mixed together.
(1) Use non-breakable packaging boxes so that they will not be
damaged by vibration, impact, dropping and stacking during
their transportation.
(2) Do not recharge batteries. Do not deform batteries.
(3) Do not mix different type of batteries.
(4) Do not solder directly onto batteries.
Storage :
Batteries shall be stored in well-ventilated, dry and cool conditions.
(1) Do not let water penetrate into packaging boxes during their
storage and transportation.
(2) Do not store the batteries in palaces of the high temperature
exceeding 35 degree Celsius or under direct sunlight or in front
of a stove. Please also avoid the place of high humidity. Be sure
not to expose the batteries to condensation, water drop or not to
store it under frozen condition.
(3) Fire fighting apparatus should be installed.
8. Prevention from exposure
Acceptable concentration : Not specified in ACGIH.
Facilities : Provide appropriate ventilation system such as local ventilator in the
storage place.
Protective clothing : Gas mask for organic gases, safety goggle, and safety glove.