RAM 1500 OWNER’S MANUAL KT1355 KT1391 Age: 3 - 5 yrs Weight: Maximum 60 lbs (28 kg) Maximum Speed: 2.5 MPH Battery: 6V7AH t WARNING! This manual contains important safety and use information. Keep this manual for future reference.
Safety 1 -- WARNING! FAILURE TO FOLLOW THE SAFETY INSTRUCTIONS LISTED BELOW MAY RESULT IN SERIOUS INJURY OR DEATH. The owner’s manual contains assembly, use and maintenance instructions. Child Safety Warnings • Adults supervising children must read and understand this entire manual before allowing any child to use this product. • Adults must evaluate their own children as to maturity, strength, judgment and ability to follow safety rules.
-- WARNING! Safe Riding Warnings Before using the ride-on toy the child should understand the controls and safety issues. They must also demonstrate the capability to handle the ride-on toy and operate its controls. It is the responsibility of the adult to educate the child and supervise the use. Explain the following safety warnings to any child using the ride-on toy before riding • Adults must teach their children not to allow other children to use this ride-on toy.
-- WARNING! Safe Riding Warnings (continued) • Do not ride in wet conditions such as rain and snow. Doing so may result in unexpected action such as tip over and skidding, as well as damage to the electrical system and battery. • Do not ride near swimming pools or other bodies of water. • Do not ride on roads, streets, near other ride-on toys or where other types of moving objects are present. • Do not ride at night or in conditions of low visibility.
WARNING! -Battery and Charging Warnings (continued) Flammable and Explosive Materials Warnings • Use of a battery or charger other than the supplied 6V rechargeable battery and charger may cause a fire or explosion. Only use the supplied 6V rechargeable battery and charger with the ride-on toy. • Do not charge the battery near heat or flammable materials. • Using the 6V recharbeable battery and charger for any other product many result in overheating, fire or explosion.
-- WARNING! Product Warning • This product can expose you to chemicals including lead, which is known to the State of California to cause cancer and birth defects or other reproductive harm. For more information go to www.P65Warnings.ca.gov. Assembly Warnings • The ride-on toy must be assembled by an adult who has read and understands the instructions in this manual. • Choking hazard to children under the age of 3 years. This ride-on toy contains small parts that are for adult assembly only.
PRE-RIDE SAFETY CHECKLIST (To be performed by a supervising adult) Before every ride, it is important to carry out the following safety checks. Do not ride a battery powered ride-on toy that is not in proper working condition! Replace any worn or broken parts as needed. Steering and Control The steering wheel or handlebars are tightened and secured in the mount or dashboard. The steering wheel or handlebars are positioned so that the rider can easily operate and steer the ride-on.
2 Parts ❶ ❷ ❹ ❸ ❽ ❼ 8 ❺ ❻ ❾ ❿
Parts List # Hardware (actual size) Part name Quantity ❶ Seat 1 ❷ Steering Wheel 1 ❸ Windshield 1 ❹ Mirrors 2 ❺ Wheel 3 ❻ Wheel snap cap 4 ❼ Wheel with Gear attachment 1 ❽ Gearbox 1 ❾ Wrench 2 ❿ Charger 1 x1 x4 x7 x1 x3 x2 Tools Required (included) Before beginning assembly, check to ensure that the parts listed above are present.
3 Assembly ❸ ❼❻❹ ❸ ❷ ❶ ❶ ❷ ❹❺❻ TIP! Place the wheel insert (step 2 & step 9) into the wheel before sliding the wheel onto the axle.
❿ ❼ ❿ ⓭⓬⓫ ❽❾ ⓫⓬⓭ TIP! When you tighten the nuts (step 12), if you attempt to tighten one nut at a time the axle will spin preventing the nut from properly tightening. Instead tighten both nuts simultaneously to ensure that all hardware is locked into place.
Windshield Assembly Mirror Assembly ❶ ❶ 12
Steering Wheel Assembly ❸ ❷ ❹ ❶ TIP! The steering wheel column is intended to have a snug fit. Because of that it can be difficult to align and install the steering wheel. To simplify assembly use your hand or have a helper push up on the wheel axle so that you can align the bolt with the drill hole in the steering column.
Connecting the Battery to the Motor ❷ ❶ 14
Seat Assembly ❷ ❸ ❶ ❶ 15
Charging the Battery WARNING! • A battery contains hazardous material that may cause serious injury or death if handled, connected, or charged improperly. Only an adult who has read and understands the warnings and instructions in this manual should handle, connect, or charge the battery. Always contact Pacific Cycle at 1-877-741-6154 if you have any questions or concerns regarding handling, connecting, or charging the battery.
Charging the Battery ❶ 18 Charge the battery for 18 hours before first use ❷ 24+ Do not charge the battery for more than 24 hours ❸ ❹ TIP! The product will not turn on while plugged into the charger. Remove from charger prior to turning on.
4 Use Controls & Functions On/Off button Forward/Reverse switch Lift foot off pedal to stop Depress pedal to accelerate Horn & Engine Sounds Note Maximum Speed: 2 MPH 18 Battery check Battery readout Skip FM Radio MP3 Input Jack Power Switch
5 Maintenance Battery Replacement and Disposal ❶ The battery will eventually lose the ability to hold a charge. Depending on the amount of use, and varying conditions, the battery should operate for one to three years. Follow these steps to replace and dispose the battery. Important! Recycle the dead battery responsibly. The battery contains lead acid (electrolyte) and must be disposed of properly and legally. It is illegal in most areas to incinerate lead acid batteries or dispose of them in landfills.
❹ ❸ 20
The ride-on toy should be checked for damage, missing or badly worn parts before each use. • Check the tightness of the fasteners before each use. • Check the tightness of the wheels before each use. • Ensure the battery is securely in place before each use. ❺ ❻ Note • Store the to ride-on toy indoors or cover it with a tarp to protect it from the wet weather. Keep it away from sources of heat, such as stoves and heaters. • Do not leave the vehicle in the sun for long periods of time or fading may occur.
6 Service Do not return this product to the place of purchase. If your ride-on toy needs service, repairs or replacement parts, call: Pacific Cycle Consumer Relations Hours: 8:00 am – 5:00 pm (CST) Monday - Friday Phone: 877-741-6154 Email: customerservice@kidtraxtoys.com For a complete list of replacement parts, please contact Pacific-Cycle Consumer Relations. To order parts, please have the model and serial number available, which can be found underneath the seat on the battery cover.
7 Warranty One Year Limited Warranty | Six-Month Limited Warranty on Battery Pacific Cycle, Inc. (PC) warrants this product to the original retail purchaser as follows: The ride-on toy (except for the 12-volt battery) is warranted against defective materials or workmanship for one year from the date of original purchase. The 12-volt battery is warranted against defective materials or workmanship for six months from the date of original purchase. An original receipt is required to validate your warranty.
In U.S.A. © 2017 Pacific Cycle Inc. 4902 Hammersly Rd. Madison, WI 53711 Styles and colors may vary.
