User manual

22
Troubleshooting Guide
Having problems with your Corvette? Read through this troubleshooting guide for
solutions to common problems. If you still experience problems, call Kid Trax Toys
Consumer Relations at [phone] for an authorized service center.
• Kid Trax Toys recommends that you take your Corvette to an authorized service
center for periodic maintenance and service.
Call Kid Trax Toys Consumer Relations
at [phone] for an authorized service center.
■ PROBLEM: The Corvette does not run.
POSSIBLE CAUSE: The battery may be low on power.
After each use, or once a month minimum, charge the battery for a full 16 hours.
Do not leave the battery on the charger for more than 30 hours. See pages 9-10 for
recharging warnings and instructions.
POSSIBLE CAUSE: Thermal fuse has tripped.
The Kid Trax Toys 12-volt battery features a thermal fuse with a reset fuse on the circuit
board that will automatically trip and cut all power to the Corvette if the motor, electric
system or the battery is overloaded. The fuse will reset after the unit is turned off and
then on again. See page 19 for tips to avoid tripping the thermal fuse.
POSSIBLE CAUSE: Wheel nuts are loose.
If the nuts are not tight, the wheels will not engage the forward gears. Use a flat-head
screwdriver to gently pry off the hubcap. Tighten the nut with the nut wrench.
POSSIBLE CAUSE: Battery connector or wires are loose.
Make sure the battery connectors is are firmly plugged into each other. If you
find loose wires around the motor, call all Kid Trax Toys Consumer Relations at
[phone] for an authorized service center.
POSSIBLE CAUSE: Battery is dead.
Have you properly maintained the battery according to the directions? Is the battery
old? Your battery may need to be replaced. Refer to the Battery Maintenance
instructions on page 19.
POSSIBLE CAUSE: Electric system is damaged.
Water may have corroded the system, or loose dirt, gravel or sand might have jammed
the switch. Call Kid Trax Toys Consumer Relations at [phone] for an authorized
service center.
POSSIBLE CAUSE: Motor is damaged.
The Corvette needs professional repair. Call Kid Trax Toys Consumer Relations at
[phone] for an authorized service center.