Manual

Natural Gas Model only:
Connecting Natural Gas To Your Grill
[] Connect the Swivel nut of the I2' Natural Gas Hose
to the vertical fitting of NG Regulator as shown in
Fig_ 1 Connect the other hose end (male plug) to
the gas supply line from house.. Also, read and foiow
all natural gas safety instructions below.
Natural Gas Safety Instructions
[]
Your natural gas grill is designed to operate on natural
gas only, at a pressure of4" water column (WC) with
natural gas regulator The gas pressure Regulator sup*
plied with this appfance must be used This Regulatoris
set for an outlet pressure of 4" WC
[]
Instal a ShutoffValve at the gas supply source outdoors
at a point after the gas pipe exits the outside wall and
before the quick-disconnect hose..Or install itat the point
before the gas line piping enters the ground. See Fig., 2
[] Pipe sealing compound or pipe thread tape resistant to
the action of natural gas must be used on all mate pipe
thread connections.
[]
Disconnect your gas grill from fuel source when the gas
supply is being tested at high pressures This gas grill
and its individual shutoff valve must be disconnected
from the gas supply pipe system during any pressure
testing of that system at pressure in excess of 1/2 psi
(35kpa)
[] Tu rn offyour gas grill when the gas supply is being tested
at low pressures The grill must be isolated from the gas
supply pipe system by closing its individual manual
shutoff valve during any pressure testing of the gas
supply pipe system at pressures equal to or less than t!
2 psi (35kpa).
Fig. 2
Inside Wall
Gas/Supply
Fig. 1
_,-J_!>) 12ft NG Hose _
_.m, L.,.JI,i _*_/"
l_ _ (not included with grill) <_:_"
i-, _,tI_;_ .... _G__
• • • _-_/ ,!IFJ -'-
Vertical filrng ..... ":_i_" ;>/_//
Swivel nut _-ii_,)
Check all connections for NG Leaks
Never test for' leaks with a lame Prior to first use and
at the beginning of each season, you must check for gas
leaks Follow these three steps:
[] Make a soap solution by mixing one part liquid
detergent and one part water
[] Turn the grill Control Knobs to the full OFF position,
then turn the gas ON at source
[]
Apply the soap solution to al gas connections indi-
cated by the arrows. See Fig. 3 if bubbles appear
in the soap solution the connections are not properly
seated. Check each fitting and tighten or repair as
necessary
Fig, 3 / ........
/
/,
_i_o Grill
Outside Wall
Shut Off
Locking
Shut Off
--- Quick
Male Fitting Disconnect
12
if you have a gas leak that cannot be repaired by
tightening, turn off the gas at the source, disconne_
fuel line from your grill and call 1-800-.4-MY-HOME
or your gas supplier for repair assistance
Never disconnect the gas regulator or any gas
filing while your gdl is lit. A lit grill can ignite
leaking gas and cause a fire or explosion which
could result in property damage, personal injury
or death