Operating instructions

ManualsBrandsKärcher ManualsBackpack VacuumsBackpack Vacuum BV 7/1 HEPA

Read these instructions before using the machine.

86394670-D

10/31/19

Operating instructions (ENG)

MODELS: VP6 1.014-013.0

VP10 1.014-014.0

WARNING:

This product and accessories may contain a chemical known to the

State of California to cause cancer and birth defects or other

reproductive harm.

For more information about this regulation: www.P65Warnings.ca.gov

Summary of content (19 pages)

PAGE 1
Operating instructions (ENG) MODELS: VP6 1.014-013.0 VP10 1.014-014.0 WARNING: This product and accessories may contain a chemical known to the State of California to cause cancer and birth defects or other reproductive harm. For more information about this regulation: www.P65Warnings.ca.gov Read these instructions before using the machine.
PAGE 2
Machine Data Label 2 86394670 - VacPac
PAGE 3
Table of Contents Machine Data Label . . . . . . . . . . . . . . . . . . . . . . . . 2 Table of Contents . . . . . . . . . . . . . . . . . . . . . . . . . 3 How To Use This Manual . . . . . . . . . . . . . . . . . . . 4 Maintenance Daily Maintenance . . . . . . . . . . . . . . . . . . . . . . . 14 Troubleshooting . . . . . . . . . . . . . . . . . . . . . . . . . 15 Service Schedule . . . . . . . . . . . . . . . . . . . . . . . . 15 Safety IMPORTANT SAFETY INSTRUCTIONS . . . . . . .
PAGE 4
How To Use This Manual The SAFETY section contains important information regarding hazardous or unsafe practices of the machine. Levels of hazards are identified that could result in product damage, personal injury, or severe injury resulting in death. This manual contains the following sections: • • • • • • How to Use This Manual Safety Operations Maintenance Parts List Options The OPERATIONS section is to familiarize the operator with the operation and function of the machine.
PAGE 5
Safety IMPORTANT SAFETY INSTRUCTIONS When using an electrical appliance, basic precaution must always be followed, including the following: READ ALL INSTRUCTIONS BEFORE USING THIS MACHINE. To reduce the risk of fire, electric shock, or injury: Do not leave the appliance when plugged in. Unplug from outlet when not in use and before servicing. Do not use outdoors or on wet surfaces. Do not allow to be used as a toy. Close attention is necessary when used by or near children.
PAGE 6
Safety IMPORTANTES MESURES DE SÉCURITÉ L'utilisation d'un appareil électrique demande certaines précautions: LIRE TOUTES LES INSTRUCTIONS AVANT DE FAIRE FONCTIONNER (CET APPAREIL). ! AVERTISSEMENT Pour réduire les risques d'incendie, de chocs électriques, ou de blessures : Ne laissez pas l'appareil sans surveillance lorsqu'il est branché. Débranchez l'appareil lorsqu'il n'est pas utilisé et avant tout entretien. Ne l'utilisez pas à l'extérieur ou sur des surfaces mouillées.
PAGE 7
Safety Hazard Intensity Level The following symbols are used throughout this guide as indicated in their descriptions: HAZARD INTENSITY LEVEL There are three levels of hazard intensity identified by signal words -WARNING and CAUTION and FOR SAFETY. The level of hazard intensity is determined by the following definitions: WARNING - Hazards or unsafe practices which COULD result in severe personal injury or death.
PAGE 8
Safety DEGRÉS DE RISQUES EN CAS DE DANGER Les symboles ci-dessous sont utilisés à travers ce manuel comme illustré dans leurs descriptions : DEGRÉS DE RISQUES EN CAS DE DANGER Il existe trois degrés de risques identifiés par les termes signalétiques -AVERTISSEMENT et ATTENTION et POUR VOTRE SÉCURITÉ. Le degré de risque est défini de la manière suivante : ! AVERTISSEMENT AVERTISSEMENT - Dangers ou méthodes dangereuses qui POURRAIENT prov aves blessures oquer de gr ou entraîner la mort.
PAGE 9
Safety Grounding Instructions Grounding Pin THIS PRODUCT IS FOR COMMERCIAL USE ONLY. GROUNDING CONNECTION USING AN ADAPTOR Grounded Grounded Outlet Box Adaptor Outlet FIGURE A ELECTRICAL: In the USA this machine operates on a standard 15 amp 115V, 60 hz, A.C. power circuit. The amp, hertz, and voltage are listed on the data label found on each machine. Using voltages above or below those indicated on the data label will cause serious damage to the motors.
PAGE 10
Safety Safety Label Location NOTE: This drawing indicates the location of safety label on the machine. If at any time the label becomes illegible, promptly replace it.
PAGE 11
NOTES 86394670 - VacPac 11
PAGE 12
Operations Technical Specifications ITEM Power Type: Electrical: Electric Vacuum Motor: Waterlift: Filter Bag: General Dimensions/Weight Vacuum Hose: Weight: Depth: Height: Width: Power Cable: 12 DIMENSION/CAPACITY 115V, 8A, 60 Hz Single Stage = 1.6 HP, 80 CFM, (2.2 Cubic Meter/Min.) 95 Inches of Water VP6/UVP6 = 6 Quart VP10/UVP10 = 10 Quart 5' (1.5m) X 1.5" (3.8cm) Diameter VP6/UVP6 = 10.1 Lb. (4.6 Kg) VP10/UVP10 = 11.0 Lb. (5.0 Kg) 10.5" (267mm) VP6/UVP6 = 19.8" (503mm) VP10/UVP10 = 23.7" (602mm) 8.
PAGE 13
Operations Equipment Set-Up Machine Operation 1. Insert hose (90° swivel cuff end) into top of unit. Attach desired cleaning tool. The unit is a commercial vacuum designed for dry pick-up only. 2. Unclip waist and sternum straps. Loosen shoulder straps and hip belt. 1. Place a paper bag inside the cloth bag in the vacuum chamber. Be sure the pleated filter is in place at the bottom of the chamber. The straps are easily adjusted while the unit is being worn. 1. To loosen lift up on tab 2.
PAGE 14
Maintenance Daily Maintenance (At the end of each working day) 1. Turn cloth filter bag inside out and brush clean. Do not use a wire brush. Cloth bags can be vacuumed with another machine or washed occasionally in warm water using a mild, water-based soap without harming filtering capacity. Allow to dry completely before using. 2. Wipe down exterior of machine. 3. Check round pleated filter at bottom of vac chamber and clean if necessary. For best results, replace the filter every six months. 4.
PAGE 15
Maintenance Troubleshooting PROBLEM. No power, vacuum motor will not run CAUSE SOLUTION Is the cord plugged in? Plug in cord. Circuit breaker tripped in building. Reset breaker. Motor will restart after cooling down. To prevent repeated tripping, clear all restrictions out of hose and tools, replace paper filter bag. Clean cloth filter bag and internal pleated filter, clear all restrictions to the exhaust air flow. Call for service. Call for service.
PAGE 16
115V HEPA VAC PAC Valid on 26.09.
PAGE 17
115V HEPA VAC PAC Valid on 26.09.
PAGE 18
115V HEPA VAC PAC POS Article no. Description Quantity Unit 1 8.619-874.0 Cap black 1.000 ST 2 8.619-909.0 Spacer back plate 2.000 ST 3 8.619-873.0 Bumper VP6/10 1.000 ST 4 8.619-890.0 FILTER BAG LINER, CLOTH VP6 1.000 ST 4 8.619-884.0 VAC PAC TM Cloth Bag for VP10 only 1.000 ST 5 8.619-891.0 FILTER BAG, VP6 PAPER PKG/10 1.000 ST 5 8.619-885.0 FILTER BAG, VP10 PAPER **(PKG/10)** 1.000 PAK 6 8.623-787.0 GASKET, 5.0ODX2.38IDX.25T 1.000 ST 7 8.639-285.
PAGE 19
28 VacPac Serial Numbers POS Description Quantity Unit 10 SERIAL NUMBER PAGE 1.000 ST Valid on 26.09.2018 Powered by TCPDF (www.tcpdf.