Report No.： PNS21085302 01041 Safety Data Sheet Name of Products: Lithium Ion Battery Pack Applicant: Ningbo FND Electronic Technology Co., Ltd. Factory： Ningbo FND Electronic Technology Co., Ltd. Tester Reviewer Approver Project Engineer Chief Engineer Chief Engineer GUANGDONG UTL CO., LTD. Address: Lianding Testing Building, No.18 Center Road of Yayuan Industrial Zone, Nancheng District, Dongguan, Guangdong, China. Tel：86-769-3893 3228 Email：utl@gdutl.com http：//www.gdutl.
TEST REPORT Report No.：PNS21085302 01041 Page 2 of 16 Identification of the product and supplier Name of goods Type/Model Lithium Ion Battery Pack 18650-2000mAh 7.4V, 2000mAh, 14.8Wh Ratings Commissioned by Commissioner address Ningbo FND Electronic Technology Co., Ltd. 5-3-4, No.6, Lane 2, Liyuan South Road, Haishu District, Ningbo City, Zhejiang Province, China Manufacturer’s name Ningbo FND Electronic Technology Co., Ltd. Manufacturer address 5-3-4, No.
TEST REPORT Report No.：PNS21085302 01041 Page 3 of 16 1. IDENTIFICATION OF THE SUBSTANCE/PREPARATION AND OF THE COMPANY/UNDERTAKING Product Identifier Product name：Lithium Ion Battery Pack Model：18650-2000mAh, Rated Capacity：7.4V, 2000mAh, 14.8Wh Other means of identification Synonyms： Recommended use of the chemical and restrictions on use Recommended Use： Uses advised against： a) Do not dismantle, open or shred secondary cells or batteries. b) Do not expose cells or batteries to heat or fire.
TEST REPORT Report No.：PNS21085302 01041 Page 4 of 16 2. HAZARDS IDENTIFICATION Classification This chemical is not considered hazardous by the 2012 OSHA Hazard Communication Standard (29 CFR 1910.1200). This product is an article which is a sealed battery and as such does not require an MSDS per the OSHA hazard communication standard unless ruptured. The hazards indicated are for a ruptured battery.
TEST REPORT Report No.：PNS21085302 01041 Page 5 of 16 SENSITIZATION-SKIN Hazard category: 1A Signal world: Warning Hazard statement: May cause an allergic skin reaction. Pictogram: Prevention：Avoid breathing dust/fume/gas/mist/vapors/spray. Wear protective gloves. Response：If on skin: Wash with plenty of water. If skin irritation or rash occurs: Get medical advice/attention. Wash contaminated clothing before reuse.
TEST REPORT Page 6 of 16 Report No.：PNS21085302 01041 3. COMPOSITION/INFORMATION ON INGREDIENTS Chemical characterization: Mixtures Description: Product: Consisting of the following components Common Chemical Name Chemical Formula Concentration (%) CAS Number LiMn2O4 38.12 12057-17-9 (C2H2F2)n 1.39 24937-79-9 Aluminium Al 9.73 7429-90-5 Graphite C 18.68 7782-42-5 Copper Cu 9.10 7440-50-8 Nickel Ni 1.56 7440-02-0 LiFP6 17.96 21324-40-3 -[CH2CH(CH3)]n- 3.
TEST REPORT Report No.：PNS21085302 01041 Page 7 of 16 4. FIRST-AID MEASURES First aid measures Eye Contact Rinse thoroughly with plenty of water, also under the eyelids. If symptoms persist, call a physician. Skin Contact Remove contaminated clothing and shoes. Wash skin with soap and water. In the case of skin irritation or allergic reactions see a physician. Inhalation Move to fresh air. If symptoms persist, call a physician. Ingestion Do NOT induce vomiting. Drink plenty of water.
TEST REPORT Report No.：PNS21085302 01041 Page 8 of 16 6. ACCIDENTAL RELEASE MEASURES Personal precautions, protective equipment and emergency procedures Personal Precautions Avoid contact with eyes. Refer to section 8 for personal protective equipment. Ensure adequate ventilation. Remove all sources of ignition. Evacuate personnel to safe areas. Environmental Precautions Environmental Precautions Refer to protective measures listed in Sections 7 and 8.
TEST REPORT Report No.：PNS21085302 01041 Page 9 of 16 8. EXPOSURE CONTROLS AND PERSONAL PROTECTION Control parameters Ingredients with limit values that require monitoring at the workplace: 12057-17-9 Lithium Manganate TLV(USA) 0.02mg/m³ MAK(Germany) 0.1mg/m³ Other Exposure Guidelines Vacated limits revoked by the Court of Appeals decision in AFL-CIO v. OSHA, 965 F.2d 962 (11th Cir., 1992).
TEST REPORT Report No.：PNS21085302 01041 Page 10 of 16 9. PHYSICAL AND CHEMICAL PROPERTIES Physician State Form: Prismatic shape Colour: Blue Odour: Odourless Odor Threshold: No information avaliable Change in condition: pH, with indication of the concentration Not determined. Melting Point/freezing point Not determined. Initial boiling point and Boiling range: Not determined. Flash Point Not determined. Evaporation rate Not determined. Flammability (solid, gas) Not determined.
TEST REPORT Report No.：PNS21085302 01041 Page 11 of 16 11. TOXICOLOGICAL INFORMATION Acute toxiciy: No data available. LD/LC50 values relevant for classification: Not available. Skin corrosion/irritation: No irritant effect. Serious eye damage/irritation: Cause serious eye irritation. Respiratory or skin sensitization: No sensitizing effects known. Specific target organ system toxicity: No information available.
TEST REPORT Report No.：PNS21085302 01041 Page 12 of 16 14. TRANSPORT INFORMATION Land transport ADR/RID class: Not regulated. UN-Number: UN3480 or UN3481 Maritime transport IMDG Class: Not regulated. UN Number: UN3480 or UN3481 Marine pollutant: No Air transport ICAO/IATA Class: Class 9 UN/ID Number: UN3480 or UN3481. Environmental hazards: Not applicable. Special precautions for user: Not applicable. Transport/Additional information: Not restricted goods according to the above specifications.
TEST REPORT Page 13 of 16 Report No.：PNS21085302 01041 CAS NO.
TEST REPORT Report No.：PNS21085302 01041 Page 14 of 16 Photos Figure 1 Overall view I of battery Figure 2 Overall view II of battery Address: Lianding Testing Building, No.18 Center Road of Yayuan Industrial Zone, Nancheng District, Dongguan, Guangdong, China. Tel：86-769-3893 3228 Email：utl@gdutl.com http：//www.gdutl.
TEST REPORT Report No.：PNS21085302 01041 Page 15 of 16 Photos Figure 3 Overall view of cell Figure 4 Label Address: Lianding Testing Building, No.18 Center Road of Yayuan Industrial Zone, Nancheng District, Dongguan, Guangdong, China. Tel：86-769-3893 3228 Email：utl@gdutl.com http：//www.gdutl.
TEST REPORT Page 16 of 16 Report No.：PNS21085302 01041 Important 1. Nobody is allowed to photocopy or partly photocopy this test report without written permission of UTL. 2. The test report is invalid without the signatures of Approver, Reviewer and Tester. 3. The test report is invalid if altered. 4. Objections to the test report must be submitted to UTL within 15 days. 5. Throughout this report a point is used as the decimal separator. 6. The test report is valid for the tested samples only. 7.
