SDS

ManualsBrandsK-Seal ManualsAdditivesK-Seal ST5501 Multi Purpose One Step Permanent Coolant Leak Repair

Revision date: 8/4/2017 Revision: 3 Supersedes date: 5/29/2015

SAFETY DATA SHEET

K-Seal

According to Appendix D, OSHA Hazard Communication Standard 29 CFR §1910.1200

1. Identification

Product identifier

Product name K-Seal

Product number ST5501, ST5516, ST7501

Recommended use of the chemical and restrictions on use

Application Additive for engine cooling systems.

Uses advised against No specific uses advised against are identified.

Details of the supplier of the safety data sheet

Supplier

Emergency telephone number

Emergency telephone

2. Hazard(s) identification

Classification of the substance or mixture

OSHA Regulatory Status This Product is Hazardous under the OSHA Hazard Communication Standard.

Physical hazards Not Classified

Health hazards Eye Irrit. 2A - H319

Environmental hazards Aquatic Acute 2 - H401 Aquatic Chronic 2 - H411

Label elements

Hazard symbols

Signal word Warning

Hazard statements H319 Causes serious eye irritation.

H411 Toxic to aquatic life with long lasting effects.

Precautionary statements P264 Wash contaminated skin thoroughly after handling.

P273 Avoid release to the environment.

P280 Wear protective gloves/ protective clothing/ eye protection/ face protection.

P305+P351+P338 If in eyes: Rinse cautiously with water for several minutes. Remove contact

lenses, if present and easy to do. Continue rinsing.

P337+P313 If eye irritation persists: Get medical advice/ attention.

P391 Collect spillage.

P501 Dispose of contents/ container in accordance with national regulations.

Solv-Tec

75 N. Main Street

Medford Lakes

NJ, 08055

USA

Tel:

609 261 4242

Fax: 609 261 4498

info@kseal.com

609 261 4242 (Monday - Friday 08:30 - 16:30h)

Summary of content (13 pages)

PAGE 1
Revision date: 8/4/2017 Revision: 3 Supersedes date: 5/29/2015 SAFETY DATA SHEET K-Seal According to Appendix D, OSHA Hazard Communication Standard 29 CFR §1910.1200 1. Identification Product identifier Product name K-Seal Product number ST5501, ST5516, ST7501 Recommended use of the chemical and restrictions on use Application Additive for engine cooling systems. Uses advised against No specific uses advised against are identified. Details of the supplier of the safety data sheet Solv-Tec 75 N.
PAGE 2
Revision date: 8/4/2017 Revision: 3 Supersedes date: 5/29/2015 K-Seal Other hazards This product does not contain any substances classified as PBT or vPvB. 3. Composition/information on ingredients Mixtures bis(D-Gluconato-O1,O2)zinc 3 - <5% CAS number: 4468-02-4 M factor (Acute) = 1 M factor (Chronic) = 1 Classification Aquatic Acute 1 - H400 Aquatic Chronic 1 - H410 4-Nonylphenol, branched, ethoxylated 1 - <2.5% CAS number: 127087-87-0 Classification Skin Irrit. 2 - H315 Eye Dam.
PAGE 3
Revision date: 8/4/2017 Revision: 3 Supersedes date: 5/29/2015 K-Seal Ingestion Rinse mouth thoroughly with water. Give a few small glasses of water or milk to drink. Stop if the affected person feels sick as vomiting may be dangerous. Do not induce vomiting unless under the direction of medical personnel. If vomiting occurs, the head should be kept low so that vomit does not enter the lungs. Skin Contact It is important to remove the substance from the skin immediately.
PAGE 4
Revision date: 8/4/2017 Revision: 3 Supersedes date: 5/29/2015 K-Seal Special protective equipment for firefighters Wear positive-pressure self-contained breathing apparatus (SCBA) and appropriate protective clothing. Standard Firefighter's clothing including helmets, protective boots and gloves will provide a basic level of protection for chemical incidents. 6.
PAGE 5
Revision date: 8/4/2017 Revision: 3 Supersedes date: 5/29/2015 K-Seal Long-term exposure limit (8-hour TWA): ACGIH 0.2 mg/m³ fume Long-term exposure limit (8-hour TWA): ACGIH 1 mg/m³ dusts and mists Long-term exposure limit (8-hour TWA): OSHA 0.1 mg/m³ fume Long-term exposure limit (8-hour TWA): OSHA 1 mg/m³ dusts and mists as Cu Refractories, fibers, aluminosilicate Long-term exposure limit (8-hour TWA): ACGIH 0.2 f/cc respirable fibers: length > 5 μm, aspect ratio >=3.
PAGE 6
Revision date: 8/4/2017 Revision: 3 Supersedes date: 5/29/2015 K-Seal Odor Mild. Odor threshold Not available. pH pH (concentrated solution): 5.9 Melting point Not available. Initial boiling point and range Not available. Flash point Not available. Evaporation rate Not available. Upper/lower flammability or explosive limits Not available. Vapor pressure Not available. Vapor density Not available. Relative density 1.045 @ 21.1°C/70°F Solubility(ies) ~92% Soluble in water.
PAGE 7
Revision date: 8/4/2017 Revision: 3 Supersedes date: 5/29/2015 K-Seal Notes (dermal LD₅₀) Based on available data the classification criteria are not met. Acute toxicity - inhalation Notes (inhalation LC₅₀) Based on available data the classification criteria are not met. Skin corrosion/irritation Animal data Based on available data the classification criteria are not met. Serious eye damage/irritation Serious eye damage/irritation Causes serious eye irritation.
PAGE 8
Revision date: 8/4/2017 Revision: 3 Supersedes date: 5/29/2015 K-Seal Toxicological information on ingredients. bis(D-Gluconato-O1,O2)zinc Toxicological effects Not regarded as a health hazard under current legislation. 4-Nonylphenol, branched, ethoxylated Skin corrosion/irritation Animal data Irritating. Serious eye damage/irritation Serious eye damage/irritation Causes serious eye damage. Copper Toxicological effects Not regarded as a health hazard under current legislation.
PAGE 9
Revision date: 8/4/2017 Revision: 3 Supersedes date: 5/29/2015 K-Seal Toxicity Aquatic Acute 1 - H400 Aquatic Chronic 1 - H410 Very toxic to aquatic life with long lasting effects. Acute aquatic toxicity LE(C)₅₀ 0.1 < L(E)C50 ≤ 1 M factor (Acute) 1 Chronic aquatic toxicity M factor (Chronic) 1 4-Nonylphenol, branched, ethoxylated Toxicity Aquatic Chronic 3 - H412 Harmful to aquatic life with long lasting effects.
PAGE 10
Revision date: 8/4/2017 Revision: 3 Supersedes date: 5/29/2015 K-Seal Ecological information on ingredients. bis(D-Gluconato-O1,O2)zinc Bio-Accumulative Potential No data available on bioaccumulation. 4-Nonylphenol, branched, ethoxylated Bio-Accumulative Potential No data available on bioaccumulation. Copper Bio-Accumulative Potential Not relevant. Mobility in soil Mobility The product is water-soluble and may spread in water systems. Ecological information on ingredients.
PAGE 11
Revision date: 8/4/2017 Revision: 3 Supersedes date: 5/29/2015 K-Seal UN proper shipping name Proper shipping name (TDG) ENVIRONMENTALLY HAZARDOUS SUBSTANCE, LIQUID, N.O.S. (CONTAINS bis(DGluconato-O1,O2)zinc, Copper) Proper shipping name (IMDG) ENVIRONMENTALLY HAZARDOUS SUBSTANCE, LIQUID, N.O.S. (CONTAINS bis(DGluconato-O1,O2)zinc, Copper (powder)) Proper shipping name (ICAO) ENVIRONMENTALLY HAZARDOUS SUBSTANCE, LIQUID, N.O.S.
PAGE 12
Revision date: 8/4/2017 Revision: 3 Supersedes date: 5/29/2015 K-Seal 15. Regulatory information Regulatory Status Classified in accordance with Appendix A, Appendix B and Appendix F of the OSHA Hazard Communication Standard 29 CFR §1910.1200. Regulatory References OSHA Hazard Communication Standard 29 CFR §1910.1200 US Federal Regulations SARA Section 302 Extremely Hazardous Substances Tier II Threshold Planning Quantities None of the ingredients are listed.
PAGE 13
Revision date: 8/4/2017 Revision: 3 Supersedes date: 5/29/2015 K-Seal Magnesium nitrate Copper Rhode Island "Right To Know" List The following ingredients are listed: Magnesium nitrate Copper Minnesota "Right To Know" List The following ingredients are listed: PEG 8000 Copper New Jersey "Right To Know" List The following ingredients are listed: Refractories, fibers, aluminosilicate Magnesium nitrate Copper Pennsylvania "Right To Know" List The following ingredients are listed: Magnesium nitrate Coppe