Submittal Sheet

Technical specifications
Table 3: Technical specifications
VG7000 Series Brass Trim Globe Valves with V-3000 Pneumatic Actuators
Service
11
Hot water, chilled water, 50/50 glycol solutions, and steam for HVAC systems
Water 35°F to 248°F (2°C to 120°C) for V-3000-800335°F to 284°F (2°C to 140°C) for V-3000-8011Fluid temperature limits
Steam 38 psig (262 kPa) Saturated steam
Water 400 psig (2,756 kPa) up to 150°F (66°C) decreasing to 365 psig (2,515 kPa) at 248°F
(120°C)
Maximum allowable
pressure/temperature
Steam 38 psig (262 kPa) saturated steam at 284°F (140°C)
Valve body pressure/temperature rating Meets requirements of ANSI B16.15, Class 250
Water 35 psig (241 kPa) for 1/2 in. through 1-1/4 in. valves
30 psig (207 kPa) for 1-1/2 in. and 2 in. valves
Maximum recommended
operating pressure drop
Steam 15 psig (103 kPa)
Two-way valves Equal percentageFlow characteristics
Three-way valves Linear flow characteristics
Rangeability
22
> 25:1 According to EN60534-2-4 for the 1/2 in. size, Cv 0.73, valve bodies
>100:1 according to EN60534-2-4 for all other valves
Leakage 0.01% of maximum flow per ANSI/FCI 70-2, Class 4
Actuator ambient operating temperature limits -20°F to 150°F (-29°C to 66°C)
Maximum actuator supply pressure 25 psig (172 kPa) maximum
Body Cast bronze
Bonnet Brass
Stem Stainless Steel
Plug Brass
Seat Brass against molded elastomeric disk
Materials
Packing Self-adjusting Ethylene Propylene Rubber (EPR) ring pack U-cups
Compliance Canada CRN: 0C22556.5
1 Refer to the VDI 2035 Guideline for recommended proper water treatment.
2 Rangeability is defined as the ratio of maximum controllable flow to minimum controllable flow.
WARNING
This product is made of copper alloy, which contains
lead. The product is therefore not to be used on drink-
ing water.
WARNING
This product can expose you to chemicals in-
cluding lead, which is known to the State of Cal-
ifornia to cause cancer, birth defects, or other
reproductive harm. For more information, go to
www.P65Warnings.ca.gov.
WARNING
WARNING: BRASS MAY CONTAIN LEAD
To fulfill our obligations towards Article 33, in ac-
cordance to the European REACH Regulation No
1907/2006 EC, we hereby inform you that this article
contains the following Substances of Very High Con-
cern mentioned on the Candidate list: Lead
Product warranty
This product is covered by a limited
warranty, details of which can be found at
www.johnsoncontrols.com/buildingswarranty.
7 VG7000 Series Brass Trim Globe Valves with V-3000 Pneumatic Actuators Catalog Page