Service Manual User guide

SECTION 6 - JLG CONTROL SYSTEM
3121262 – JLG Lift – 6-111
240 24 0 <<< OTHER CONTROLS >>>
250 25 0 <<< FUNCTION PREVENTED >>>
259 25 9 MODEL CHANGED - HYDRAULICS SUSPENDED - CYCLE
EMS
The model selection has
been changed.
2513 25 13 GENERATOR MOTION CUTOUT ACTIVE Driving is not possible
while the vehicle generator
is running AND is config-
ured to prevent drive.
2514 25 14 BOOM PREVENTED - DRIVE SELECTED Boom functions are not
possible while the vehicle
is being driven AND is con-
figured to not allow simulta-
neous drive & boom
operation.
2515 25 15 DRIVE PREVENTED - BOOM SELECTED Driving is not possible
while the vehicle above
elevation AND is config-
ured to prevent drive while
above elevation.
2516 25 16 DRIVE PREVENTED - ABOVE ELEVATION Driving is not possible
while Boom functions are
selected AND is configured
to not allow simultaneous
drive & boom operation.
2517 25 17 DRIVE PREVENTED - TILTED & ABOVE ELEVATION Driving is not possible
while the vehicle is tilted
and above elevation AND
is configured to prevent
drive while tilted and above
elevation.
2521 25 21 JIB SWING PREVENTED - IN 1000# MODE JIB Swing is not possible
while the vehicle is in 1000
LB Mode.
2522 25 22 CAN DONGLE ATTACHED - HYDRAULICS NOT
RESTRICTED
CAN Dongle attached.
Very limited restrictions for
all hydraulics systems.
2546 25 46 MACHINE SETUP FAULT - JIB SWING
2547 25 47 MACHINE SETUP FAULT - MODEL
330 33 0 <<< GROUND OUTPUT DRIVER >>>
331 33 1 BRAKE - SHORT TO BATTERY There is a Short to Battery
to the Brake Valve.
332 33 2 BRAKE - OPEN CIRCUIT There is an Open Circuit to
the Brake Valve.
3311 33 11 GROUND ALARM - SHORT TO BATTERY There is a Short to Battery
to the Ground Alarm.
- Ground Alarm equipped
vehicles only.
3316 33 16 RIGHT FORWARD DRIVE PUMP - SHORT TO GROUND There is a Short to Ground
to the Right Forward Drive
Valve.
- Chassis Module equipped
vehicles only.
Table 6-8. Diagnostic Trouble Code Chart
DTC
Flash
Code
Sequence
Fault Message Fault Description Check