Parts Manual Manual

ManualsBrandsJLG ManualsSpecial machinery1500SJ

3121263 1500SJ 2-33

SECTION 2 TURNTABLE

205 4 Injector Pump Options:

Ref Note: Series Letter is shown on label at base of Injector

Pump.

70001128 AR “A Series

70001129 AR “B Series

70001130 AR “C Series

70001131 AR “D Series

206 7016328 1 Filter, Fuel

207 70000916 1 Pump Fuel Supply

70001435 1 Repair Kit

70000917 1 O-Seal Between Fuel Pump & Engine Block (Not Shown)

70000919 1 Pump, Hand (Not Shown)

208 7020414 1 V-Belt

209 7020471 4 Gasket, Exhaust Manifold to Cylinder Head (Not Shown)

7020486 1 Gasket, Exhaust Manifold to Exhaust Pipe (Not Shown)

210 70001867 1 Alternator Options:

70004292 Alternator for Tier IVi-Flex Engines

70001867 Alternator for Tier III, Tier IVi & Tier IVi-PRE Engines

70001868 Regulator, Voltage (Not Shown)

70001866 Seal (Not Shown)

211 7020479 1 Starter (Not Shown - Located on Right Side of Engine)

1 Solenoid Options:

70004058 Solenoid for Tier IVi-Flex Engines

7026608 Solenoid for Tier III, Tier IVi & Tier IVi-PRE Engines

70001498 1 Baffle, Cooling (Not Shown)

212 7027791 1 Sender, Coolant Temperature

213 7027790 1 Sensor, Oil Pressure

214 1 Sensor, Speed Options:

70004272 Sensor for Tier IVi-Flex Engines

7024565 Sensor for Tier III, Tier IVi & Tier IVi-PRE Engines

215 7027792 1 Actuator, Throttle

7027276 2 Spring

216 Use 70003475 1 Thermostat (was p/n 7020459)

217 70001870 1 Flywheel (Not Shown)

7024579 1 Gear, Ring (Not Shown)

218 70003472 1 Bracket, Oil Filter (includes Temperature Sensor Components)

7027236 1 Sensor, Temperature

700025082 1 Ring, Sealing

70003473 1 Gasket, Bracket to Engine Block (Not Shown)

219 7027239 1 Solenoid, Start (Not Shown)

220 7027240 1 Turbocharger (Not Shown)

70001857 1 Flange, Turbocharger (Not Shown)

70001135 1 Gasket (Not Shown)

70002675 2 Clamp (Not Shown - Used on Sleeve rising vertically from

Tur bo )

70002676 1 Sleeve, Rubber (Not Shown - Rises vertically from Turbo)

221 7027795 1 Module, Engine Control

7027796 1 Harness, Controller (Not Shown)

FIGURE 2-6. DEUTZ TD2011 ENGINE INSTALLATION (CONTINUED)

ITEM # PART NUMBER QTY. DESCRIPTION REV.