Report No.: PNS211201010 01001 Safety Data Sheets Name of Goods: Commissioner: Rechargeable Li-ion Battery Pack Shenzhen Hello Tech Energy Co., Ltd GUANGDONG UTL CO., LTD.
Page 1 of 12 Report No.: PNS211201010 01001 Safety Data Sheet (SDSs) Name of goods Type/Model Type Commissioned by Commissioner address Rechargeable Li-ion Battery Pack JE-2000A 43.2V, 50Ah, 2160Wh Shenzhen Hello Tech Energy Co., Ltd F2-3, Bldg. 7, Jiaanda Science and technology Industrial Park Factory, The East Side of Huafan Road, Tongsheng Community, Dalang Street, Longhua District, Shenzhen, Guangdong, China Manufacturer’s name Shenzhen Hello Tech Energy Co.
Page 2 of 12 Report No.: PNS211201010 01001 1. IDENTIFICATION OF THE SUBSTANCE/PREPARATION AND OF THE COMPANY/UNDERTAKING Product Identifier Product name：Rechargeable Li-ion Battery Pack Model：JE-2000A , 43.2V, 50Ah, 2160Wh Other means of identification Synonyms： Recommended use of the chemical and restrictions on use Recommended Use： Uses advised against： a) Do not dismantle, open or shred secondary cells or batteries. b) Do not expose cells or batteries to heat or fire.
Page 3 of 12 Report No.: PNS211201010 01001 Emergency telephone number : N/A Company Emergency Phone Number:+86-755-29106556 2. HAZARDS IDENTIFICATION Classification This chemical is not considered hazardous by the 2012 OSHA Hazard Communication Standard (29 CFR 1910.1200). This product is an article which is a sealed battery and as such does not require an MSDS per the OSHA hazard communication standard unless ruptured. The hazards indicated are for a ruptured battery.
Page 4 of 12 Report No.: PNS211201010 01001 Response：If in eye: Rinse cautiously with water for several minutes. Remove contact lenses, if present and easy to do. Continue rinsing. If eye irritation persists: Get medical advice/attention. Storage: Disposal: SENSITIZATION-RESPIRATORY Hazard category: 1A Hazard statement: May cause allergy or asthma symptoms or breathing difficulties if inhaled Prevention：Avoid breathing dust/fume/gas/mist/vapors/spray.
Page 5 of 12 Report No.: PNS211201010 01001 3. COMPOSITION/INFORMATION ON INGREDIENTS Chemical characterixation: Mixtures Description: Product: Consisting of the following components Common Chemical Name Chemical Formula Concentration (%) CAS Number LiNixCoyMn1-x-yO2 36.5 182442-95-1 C24X12 21.4 7782-42-5 Polyvinylidene Fluoride (PVDF) (CH2-CF2)n 0.5 24937-79-9 Carboxymethylcellulose C8H16NaO8 0.3 9000-11-7 C 0.5 1333-86-4 (C8H8.C4H6)x 0.5 9003-55-8 (C3H6)n 0.
Page 6 of 12 Inhalation Report No.: PNS211201010 01001 Move to fresh air. If symptoms persist, call a physician. Ingestion Do NOT induce vomiting. Drink plenty of water. If symptoms persist, call a physician. Most important symptoms and effects, both acute and delayed Swallowing Do not induce vomiting. Get medical attention. Most Important Symptoms/Effects No information available. Indication of any immediate medical attention and special treatment needed Notes to Physician Test symptomatically 5.
Page 7 of 12 Report No.: PNS211201010 01001 Refer to section 8 for personal protective equipment. Ensure adequate ventilation. Remove all sources of ignition. Evacuate personnel to safe areas. Environmental Precautions Environmental Precautions Refer to protective measures listed in Sections 7 and 8. Absorb with liquid-binding material (sand, diatomite, acid binders, universal binders, sawdust). Dispose contaminated material as waste according to item 13.
Page 8 of 12 Report No.: PNS211201010 01001 Ingredients with limit values that require monitoring at the workplace: 12190-79-3 Lithium Cobalt Oxide TLV(USA) 0.02mg/m³ MAK(Germany) 0.1mg/m³ Other Exposure Guidelines Vacated limits revoked by the Court of Appeals decision in AFL-CIO v. OSHA, 965 F.2d 962 (11th Cir., 1992).
Page 9 of 12 Report No.: PNS211201010 01001 Change in condition: pH, with indication of the concentration Not determined. Melting Point/freezing point Not determined. Initial boiling point and Boiling range: Not determined. Flash Point Not determined. Evaporation rate Not determined. Flammability (solid, gas) Not determined. Upper/lower flammability or explosive limits Not determined. Vapor Pressure: Not determined. Vapor Density: Not determined. relative density: Not determined.
Page 10 of 12 Report No.: PNS211201010 01001 Hazardous Polymerization: Hazardous polymerization does not occur. Conditions to avoid: Strong heating, fire, Incompatible materials. Incompatible materials: Strong oxidizing agents. Strong acids. Base metals. Hazardous Decomposition Products: Carbon oxides, Other irritating and toxic gases. 11. TOXICOLOGICAL INFORMATION Acute toxiciy: No data available. LD/LC50 values relevant for classification: Not available. Skin corrosion/irritation: No irritant effect.
Page 11 of 12 Report No.: PNS211201010 01001 Land transport ADR/RID class: Not regulated. UN-Number: UN3480 or UN3481. Maritime transport IMDG Class: Class 9. UN Number: UN3480 or UN3481. Marine pollutant: No Air transport ICAO/IATA Class: Class 9 UN/ID Number: UN3480 or UN3481. Environmental hazards: Not applicable. Special precautions for user: Not applicable. Transport/Additional information: Not restricted goods according to the above specifications.
Page 12 of 12 Report No.: PNS211201010 01001 61789-96-6 Not listed Listed Not listed DSL Listed Listed Listed 24937-79-9 Listed Listed Listed DSL Listed Listed Listed 21324-40-3 Listed Not listed Not listed Not listed Not listed Not listed Not listed 7440-44-0 Listed Not listed Not listed Not listed Not listed Not listed Listed Chemical safety assessment A Chemical Safety Assessment has not been carried out 16.
