MSDS

Aqua-Gel® CW Wire Pulling Lubricant
SECTION IV - HEALTH HAZARD INFORMATION
EFFECTS OF OVEREXPOSURE - Conditions to Avoid
None normally expected. Upon prolonged contact, may cause temporary eye
discomfort.
THRESHOLD LIMIT VALUE
N.E.
PRIMARY ROUTES OF ENTRY Inhalation Skin Contact Other (specify)
EMERGENCY FIRST AID PROCEDURES
SKIN CONTACT: Wash with soap and water for 15 minutes.
EYE CONTACT:
Flush with water for 15 minutes. Inhalation- Move to fresh air.
INGESTION:
Administer water or milk. Consult physician or local poison control center.
SECTION V - REACTIVITY DATA
UNSTABLE
CONDITIONS TO AVOID
Avoid prolonged storage at temperatures exceeding 180 F.
STABLE
X
INCOMPATIBILITY (materials to avoid)
Avoid Strong oxidizers and nitrates.
HAZARDOUS DECOMPOSTION PRODUCTS:
Oxides of carbon and nitrogen
MAY OCCUR
CONDITIONS TO AVOID None
WILL NOT OCCUR
X
SECTION VI - SPILL AND LEAK PROCEDURES
STEPS TO BE TAKEN IF MATERIAL IS RELEASED OR SPILLED
Wipe up, shovel or vacuum spilled material.
Clean up spills immediately as they can be dangerously slippery.
WASTE DISPOSAL METHOD
Comply with Federal, state and local regulations for solid lanfill.
CERCLA (Superfund) REPORTABLE QUANTITY (in lbs)
N/A
RCRA HAZARDOUS WASTE NO. (40CFR 261.33)
N/A
VOLATILE ORGANIC COMPOUND (VOC) (as packaged, minus water)
4.1 gms / ltr.
³ Theoretical lb/gal N/A
³ Analytical lb/gal N/A
SECTION VII - PERSONAL PROTECTION INFORMATION
RESPIRATORY PROTECTION (specify type)
None normally required
LOCAL EXHAUST (Specify Rate) None
SPECIAL None
MECHANICAL (General) (Specify Rate)
Recommended in closed areas.
OTHER None
PROTECTIVE GLOVES (specify type)
None normally needed-Neoprene if necessary
EYE PROTECTION (specify type)
Safety glasses or splash goggles.
OTHER PROTECTIVE EQUIPMENT
Eye fountain in work area is recommended.
SECTION VIII - SPECIAL PRECAUTIONS
PRECAUTIONS TO BE TAKEN IN HANDLING AND STORING
Store at temperatures between -40 - +180 F.
OTHER PRECAUTIONS
Keep away from children, infants and pets.
SECTION IX - ADDITIONAL INFORMATION
Do not mix with nitrites. Under extreme temperatures, contact with nitrites could result in the formation of
nitrosamines which are potential carcinogens.
N/A = Not Applicable, N.E. = None Established
THIS MATERIAL SAFETY DATA SHEET PREPARED BY:
NAME James R. MacMurdo
SIGNATURE
TITLE Manager, Construction Market Dev.
DATE 11/29/2010
STABILITY
HAZARDOUS
POLYMERIZATION
VENTILATION