Installation guide

I Blower Cabinet Installation Instructions
Figure 8 J Electrical Data
NOM HEATER WIRE
PART UNIT HEATER MIN WIRE MIN MAX CIRCUIT
CAPACITY RATING
NO. SIZE VOLTAGE KW @ AMPS SIZE* AMPACITY PROTECTION
240-V (BTUH) (°C)
018
AMWK001CK 024 208/230 0 0.0/0.0 0/0 75 14 2.5 15/15
O3O
018
AMWK005AH 024 208/230 5.0 18.1/20.0 12799/15700 75 10/10 25,2/27.5 30/30
O3O
018
AMWK007AH 024 208/230 7.5 27.1/30.0 19215/23515 75 8/8 36.4/40.0 40/40
O3O
018
AMWK011AH 024 208/230 11.0 39.8/44.0 25597/31331 75 6/6 52.3/57.5 60/60
O3O
( SCHEMATIC DIAGRAM ) CAUTION: "_
NOTSUITABLEFORUSEONSYSTLMSEKCEEDING/C_VTOGROUND
SEE RATING PLATE FOR MOLTS& HERTZ ATTENTION:
FIELDPOWERWIRING NECQNVJENTPA5AI_(JNSTALLATIQNSDEPLUSDE/5OVALATERRE
SEENOmE_t© ©
ii I ii ISCONNECT PER _] [_o
_I_I _i , lil lil_
_,,_ , I,O I hO I_-
O to to tO zO
z\_J\J GNO\_J
SEENOTEO
--I YEL YEL BLK I
LS2 HTR2 BLK BLK
YEL_ELAY I_BLK '
LS1 HTR1 BLK j
__ _F --RELAY 1
/ B,LKI =VDCCOlL
I I, ' I _g_
I BtUBLK.... BLK__r
SPT / ORI N VIO
Yf_YIIEL ___'F_-ORNRE_ D FJ !RY
YE£ BRN VIO
BRN BRN I
/ s_;..!RNL22 IIiI_F]P a
I-- HIL_--YBELLK_ _ ' -B-,_R-RIER_-- - -S-E-E-N-OT-E#-7
.__LO__Rg..j_'RN_ELBRN_¢__
(,_ COMPONENTARRANGEMENT _)
SYSTEM TRANSFORMER: 4O.OVA
FAN COIL/HEATER: 814VA
REMAINING VA AVAILABLE: 31.GVA
•
RELAY 1 RED COM
I_ 24V 208 V
S 230 V _
, REC i _ -c _
i i =T/; F
DISC _] PCB
GND @ @
__RED-LOW
GND BLK-HI BRN
OM
SEE NOTE &5
FAN MOTOR THERMALLY PROTECTED
LEGEND
GND TH ERBADSTAT UNIT
1 Use copper v4re (75°c rain} only between disconnect switch and unit,
2 To be v4red in accordance w_thnec and local codes
3 If any of the ori_nal wire, as supplied, must be re#aceq, use the same or
equivalent type wire.
4 Re#ace low voltage fuse with no greater than 5 AMP fuse
5 (2) Speed Motor uses HI (ELK) and LOW (RED)
6 Smaller heaters vviflhave fewer components
7 Connect R to R, Gto G, etc., see outdoor instructionsfor details
8 Cocling controls wipeg not used with e]ectpe heaters
Thiscompartmentmustbe closedexcept
when servicing.
_ ROTATION 1324494-101REV,A I
CAP CAPACITOR
COM COMMON
DISC DISCONNECT
F FUSE
FM FAN MOTOR
_ FIELD POWER WIRING
FR PCB FAN RELAY
GND EQUIPMENT GROUND
HTR HEATER
LS LIMIT SWITCH
C) MARKED ]_RMINAL
-_>- PLUG AND RECEPTACLE
PCB PRINTED CIRCUIT BOARD
REC RECTIFIER
SPT FAN SPEED TAP LOCATION
TRAN TRANSFORMER
O UNMARKED TERMINAL
FAN COIL SIZE I01S10241030
MOTOR SPEED ONE _R I LO I LO I LO
IMOTO_ SPEED TWO HTR I LO I LO I_o_
664 01 3001 O0 7L_ J