User Guide
Fuel system
DANGER: Observe usual fuel handling precautions:
Do not smoke while refueling.
Do not fill tank with engine running or while engine is hot.
Clean up any gasoline spills.
Allow engine to cool before storing machine inside a
building.
Keep fuel away from open flame or spark and store machine
away from open flame or spark if there is fuel in the tank.
Use extra caution when handling gasoline and other fuels.
They are flammable and vapors are explosive. A fire or
explosion from gasoline can burn you and others and can
damage property.
Refuel outdoors preferably, or in well ventilated areas.
Never attempt to start engine when there is a strong odor of
gasoline fumes present. Locate and correct cause.
Store gasoline in an approved container and keep it out of the
reach of children. Never buy more than a 30 day supply of
gasoline.
Always place gasoline containers on the ground away from
your vehicle before filling.
Do not fill gasoline containers inside a vehicle or on a truck
or trailer as interior carpets or plastic truck bed liners may
insulate the container and slow the loss of any static charge.
When practical, remove equipment from the truck or trailer
and refuel the equipment with its wheels on the ground. If
this is not possible, then refuel the equipment on the truck or
trailer using a portable container and not a gasoline dispenser
nozzle. If a gasoline dispenser nozzle must be used, keep the
nozzle in contact with the rim of the fuel tank or container
opening at all times until fueling is complete.
WARNING: Gasoline is harmful or fatal if swallowed.
Long-term exposure to vapors can cause serious injury and
illness.
Avoid prolonged breathing of vapors.
Keep face away from nozzle and gas tank or conditioner
opening.
Keep gas away from eyes and skin.
The fuel tanks are located in the tractor’s fenders. (Fig. 9-7) Total
capacity for the fuel tanks is 6 U.S. gallon (22.71 liter).
IMPORTANT: Do not overfill the fuel tanks. The fuel tanks should
be filled no higher than 2” below the tank’s fill neck.
When filling the fuel tanks disengage deck clutch, place control levers
in park brake position, and stop tractor engine. Clean around the fuel tank
cap and remove the cap and begin filling. When finished, screw the cap on
securely and wipe up any spilled gasoline.
Use regular unleaded gasoline with an octane rating of 87 or higher.
IMPORTANT: Never use methanol, gasoline containing methanol, or
gasohol containing more than 10% ethanol because the fuel system could be
damaged. Do not mix oil with gasoline.
Using a fuel stabilizer/conditioner in the tractor can provide benefits
such as:
1. Keeps gasoline fresh during storage of 90 days or less. For longer
storage, drain the fuel tanks.
2. Cleans the engine during operation.
3. Eliminates gum-like varnish buildup in the fuel system.
IMPORTANT: Do not use fuel additives containing methanol or
ethanol.
Add the correct amount of gas stabilizer/conditioner to the gas. Follow
the gas stabilizer/conditioner manufacturer’s directions for best results.
The fuel filter (Fig. 9-8A & 9-8B) is installed in the fuel line between
fuel tanks and engine fuel pump. Replace filter annually or after every 100
hours of operation, whichever occurs first. For fuel filter removal refer to
the engine owner’s manual
When replacing the fuel filter, check the fuel line hoses and fuel tank
fitting grommets for any cracks or leaks. Replace as needed.
A fuel shut-off valve is located to the right rear of the seat. Fig. 9-9
Close this valve (center position) to prevent fuel flow to the engine. Close
this valve when transporting the unit on a trailer or truck.
Draining the fuel tank
1. Park the unit on a flat surface. Stop the engine and remove the
Figure 9-8A
Honda
Fuel filter
Inlet hose
Figure 9-6
Figure 9-7
Fuel tank
.75” - 1.50” Depth
at 50
o
- 100
o
F
333559_0806
9-8