User Manual

6
Lithium-Ion Battery & charger Warnings:
The following safety hazards may result in serious
injury or death to the user of the vehicle:
• Battery Charger for Indoor use only. Use of a battery or charger other than the supplied
rechargeable battery and charger may cause a  re or explosion. Only use the supplied
rechargeable battery (or lead-acid or lithium suitable replacement) and charger with the
vehicle.
• Using the rechargeable battery and charger for any other product may result in
overheating,  re or explosion. Never use the rechargeable battery and charger with
another product.
• Explosive gases are created during charging. Charge the battery in a well ventilated area.
Do not charge the battery near heat or  ammable materials.
• Contact between the positive and negative terminals may result in  re or explosion. Avoid
direct contact between the terminals. Picking up the battery by the wires or charger can
cause damage to the battery and may result in a  re. Always pick up the battery by its case
or handles.
• Battery must be handled by adults only. Liquids on the battery may cause  re or electric
shock. Always keep all liquids away from the battery and keep the battery dry.
• Contact or exposure to battery leakage may cause serious injury. If contact or exposure
occurs immediately call your physician. If the chemical is on the skin or in the eyes,  ush
with cool water for 15 minutes. If the chemical was swallowed, immediately give the per-
son water or milk. Do not give water or milk if the patient is vomiting or has a decreased
level of alertness. Do not induce vomiting.
• Battery Posts, terminals and related accessories contain lead and lead compounds (acid),
chemicals known to cause cancer, reproductive harm and are toxic and corrosive. Never
open the battery.
• Tampering or modifying the electric circuit system may case a shock,  re or explosion and
permanently damage the system. Exposed wiring and circuitry in the charger may cause
electric shock. Always keep the charger housing closed.
• Non-rechargeable batteries are not to be recharged.
• Batteries are to be inserted with the correct polarity
• The supply terminals are not to be short-circuited.
• Batteries are only to be charged by adults.
• The battery chargers used with the toy are to be regularly examined for damage to the
cord, plug, enclosure and other parts, and in the event of such damage, they must not be
used until the damage has been repaired.
• All large lithium batteries are a potential  re risk and should be charged in a safe place,
preferably outside or in the middle of a garage  oor.
• Never charge a lithium battery unsupervised inside a house or building.
• Only an adult who has read and understands the safety warnings should handle, charge or
recharge of the battery.
Warnings and Safety
31
Maintenance
Drive Battery Replacement
A
C
E
D
B
STEPS:
1. Insert and turn Key fully Counter Clockwise before starting.
2. Pull top of Battery to the LEFT and out to remove from Mount.
3. Remove new Battery from packing. Make sure no packing remains around Slot and Plug
A
.
4. On bottom of Battery, align Slot and Plug
A
with Tab and Pins
B
on Battery Mount
and swing into place so that Battery
Notch
C
slides into top of Battery
Mount
D
.
5. With Battery fully in place, turn Key fully
Clockwise
E
to lock Battery in place.
6. Gently pull on battery to make sure it
does not come lose. Remove key and
keep in a safe place.
7. See Battery Charge section for Charging
instructions.