Safety data sheet

NO. SCUD201801036
Issue data: 2018-01-01
Cells and/or batteries at a SOC of greater than 30% of their rated
capacity may only be shipped with the approval or the State or Origin and the
State or the Operator under the written condions established by those
authorities
Packages prepared according to Section II or PI965 must be offered to
the operator separately from other cargo and must not be loaded into a unit
load device before being offered to the operator.
Do not damage or mishandle this package. If package is damaged,
batteries must be quarantined, inspected ,and repacked. Cells and batteries
identified bu the manufacturer as being defective for safety reasons, or that
have been damaged,that have the potential of producing a dangerous
evolution of heat, fire recycling or disposal are prohibited from air transport
unless approved by the appropriate national authority of the State of origin and
the State of the operator.
The lithium battery should pass the UN38.3 test, if the battery can not
pass the testing, it can not transport, should redesign. Redesign. If the battery
through the lithium battery only,follow the UN3480 and the packing
requirements for PI967.
The lithium battery testing meets all requirements under UN Manual of
Tests and Criteria Part III subsection 38.3
14.2The requirement of ocean shipping
According to International Maritime Dangerous Goods Code(2014Edtion)
to transport and according to the requirements of UN NO. 3480/3481 to
management the goods, and require class II packaging Firmly
installation.mutual isolation. Avoid short circuits. If the package contain more
than 24 lithium batteries or more than 12 lithium battery packs, must provide
the special program if package damage.
The clause 188 of IMDG require the Watt of lithium ion batteries no more
than 100 WH, and must marked the WHR ratio label. Otherwise, the battery
and module should packed in a strong outer packaging or be contained in
equipment.
The clause 230 of IMDG 38
th
require the lithium battery testing should
meets all requirements under UN Manual of Tests and Criteria Part III ,
subsection 38.3
Shipping Name: Lithium ion batteries
Hazard Class:9*
UN Number: 3480/3481