Refrigerator Model HR24C Number: MAN-328-R Issued: 03-14-2019 Revised: 03-22-2019
WARNING Only qualified service technicians should install and service the appliance. To obtain the name and phone number of your local Hoshizaki Certified Service Representative, visit www.hoshizaki.com. No installation or service should be undertaken until the technician has thoroughly read this Instruction Manual. Likewise, the owner/manager should not proceed to operate the appliance until the installer has instructed them on its proper operation.
IMPORTANT This manual should be read carefully before the appliance is installed and operated. Read the warnings and guidelines contained in this manual carefully as they provide essential information for the continued safe use and maintenance of the appliance. Retain this manual for any further reference that may be necessary. TABLE OF CONTENTS Introduction ............................................................... Important safety information ..................................... General safety ....
INTRODUCTION This manual contains instructions for installation, operation and general maintenance of your unit. Important Safety Information Throughout this manual, notices appear to bring your attention to situations which could result in death, serious injury, damage to the appliance, or damage to property. Indicates a hazardous situation that, if not avoided, will DANGER result in death or serious injury.
WARNING This appliance should be destined only to the use for which it has been expressly conceived. Any other use should be considered improper and therefore dangerous. The manufacturer cannot be held responsible for injury or damage resulting from improper, incorrect, and unreasonable use. Failure to install, operate, and maintain the appliance in accordance with this manual will adversely affect safety, performance, component life, and warranty coverage.
WARNING, continued • • • • • • • • • • • • • • • • 6 This appliance is not intended for use by persons (including children) with reduced physical, sensory, or mental capabilities, or lack of experience and knowledge, unless they have been given supervision or instruction concerning use of the appliance by a person responsible for their safety. Children should be properly supervised around this appliance. Do not climb, stand, or hang on the appliance or door or allow children or animals to do so.
WARNING, continued • • • • • Do not allow children to climb, step or hang onto the shelves inside the cooler. That could damage the unit and cause serious injuries to them. Do not touch the cold surfaces of the cooler with your hands wet or moist. The skin can stick to these cold surfaces. Do not store gasoline or other flammable liquids or gases, near this or other electrical equipment.
KNOW YOUR EQUIPMENT DOOR CONTROL MODULE POWER CORD LEVELING LEG PULL OUT SHELF FIG.
CHECK FOR SHIPPING DAMAGE Prior to leaving the factory, each cabinet is throughly inspected and performance tested to assure proper operating temperatures. Check the crate thoroughly for signs of shipping damage. If external damage exists, internal damage is also probable. Uncrating should be done while the carrier´s representative is present. Otherwise, the equipment should be uncrated as soon as possible, preferably within five (5) days.
HANDLING THE CABINET 1. Always move the unit in an upright position. Do not set it on its side or upside down as you may damage the cabinet and cause the oil to migrate from the compressor. 2. If lifting the unit, hold it from its base. It is recommended to use a dolly. 3. Do not let the unit fall abruptly. 4. Appliance is heavy. Use care when lifting or positioning. Work in pairs when needed to prevent injury or damage. 5. Do not lift using the doors.
ELECTRICAL INSTALLATION Electrical Connection WARNING • • • • • • • • • Electrical connection must meet national, state, and local electrical code requirements. Failure to meet these code requirements could result in death, electric shock, serious injury, fire, or severe damage to equipment. This appliance requires an independent power supply of proper capacity. See the nameplate for electrical specifications.
INSTALLING THE SHELVES Loading tips and suggestions Your appliance is equipped with a shelf system, composed of three reinforced heavy duty shelves and twelve shelf clips (four per shelf), which provides maximum adjustability. WARNING Never try to move a loaded shelf, remove everything from the shelf before moving. Use both hands when moving the shelf. To add or remove a shelf Remove stored product from the shelf. Do not try to remove a loaded shelf from the appliance.
DOOR REVERSAL If you would like to reverse the door swing, follow the steps below. Otherwise, skip to section “Controls and adjustments”. TOOLS PHILLIPS # 2 SCREWDRIVER INSTRUCTIONS Step 1. Remove the four SC-48-SS screws and the Exterior top. See figure 3. Exterior top SC-48-SS screw (use screwdriver) FIG.
Step 2. While maintaining a hold on the door, remove the SC-48-SS screws, the HA-609-SS Lower Hinge and the HA-608-SS Upper Hinge, then remove the door. See figure 4. HA-608-SS Upper Hinge SC-48-SS Screw (use screwdriver) HA-609-SS Lower Hinge FIG. 4 Step 3. Remove the SC-50-SS screws, the HA-634-SS Door handle, and the TA-14 Plastic plugs, then attach them to the opposite side. See figure 5.
Step 4. Attach the Hinges to the left side of the cabinet. See figure 6. HA-608-SS Upper Hinge HA-609-SS Lower Hinge FIG. 6 Step 5. Finally attach the Exterior Top. See figure 7. Exterior Top FIG.
CONTROLS AND ADJUSTMENTS DEFROST SELECTOR STEPS TO CHANGE SETPOINT 1. To access the menu press the “Set” button until the value “0” is displayed on the screen. 2. Release the “Set” button. 3. Press the “Up” button repeatedly until the value 22 is displayed on the screen. This is the password. 4. Push the “Set” button once to access the menu. 5. When you access the menu the display shows the letters “PS”. 6. Press the “Up” button repeatedly until “St” appears in the display, then press the “Set” button. 7.
To obtain the name and phone number of your local Hoshizaki Certified Service Representative, visit www.hoshizaki.
Cleaning CLEANING AND MAINTENANCE INSTRUCTIONS WARNING Before cleaning the appliance, turn off and unplug the appliance to prevent electric shock by unexpected entrance of water into the appliance or injury by moving parts. Before cleaning the appliance, move all items into another refrigerator. Do not splash water directly onto the appliance. This might cause short circuit, electric shock, corrosion, or failure.
PREPARING THE APPLIANCE FOR PERIODS OF NON-USE Shutdown and Long Storage When shutting down the appliance for more than one week, follow the instructions below. WARNING When preparing the appliance for long storage, prevent the door from closing to reduce the risk of children getting trapped. Leave the shelves in place so that children may not easily climb inside. IMPORTANT When preparing the appliance for long storage, clean the cabinet interior, door gaskets, and shelves. 1. 2. 3. 4.
618 Hwy. 74 South, Peachtree City, GA 30269 USA (P) 770.487.2331 (F) 770.487.3360 hoshizakiamerica.
