Portable Evaporative Air Cooler OWNER’S MANUAL Read and save these instructions before use Model: CO301PC Power rating: 270 Watts Voltage rating: 220-240 Volt, 50Hz Made in P.R.C.
INDEX Read all instructions carefully before setting up and operating the unit, and please keep this instruction manual for future reference. This manual is designed to provide you with important information needed to setup, operate, maintain, and troubleshoot your cooler. Failure to follow these instructions may damage and/or impair its operation and void the warranty. SECTION 1. 2. 3. 4. 5. 6. 7. 9. 9. PAGE THANK YOU .....................................................................................
THANK YOU THANK YOU! Congratulations on your purchase of this versatile Honeywell Evaporative Air Cooler. For optimum cooling performance from your unit, fill the water tank with water & ice (if available) to increase its cooling power. Please read these instructions carefully.
USER TIPS COOL ~ EFFICIENT ~ NATURAL Evaporative air cooling is the natural way of cooling, similar to a breeze blowing across a lake. This breeze drops the temperature and has a relaxing cooling effect. The evaporative air cooler cools the air by means of the evaporation of water. When water evaporates into the air, the result is a mixture of air and water molecules. This chemical change requires heat which is taken from the water molecules, resulting in cooler air propelled from the unit.
USER TIPS The recommended maximum relative humidity level is 60% or less, which allows a noticeable temperature decrease. The temperature decrease will be greater in drier climates because higher evaporation occurs when the humidity is low. The evaporative air cooler must be kept at floor level and there must be water in the water tank. The room should have doors and windows opened to allow free air flow.
SAFETY RULES READ AND SAVE THESE INSTRUCTIONS: When using electrical appliances, basic safety precautions should always be followed: • Your cooler runs on 220-240 Volt AC, 50 Hz current. Check the household voltage to ensure it matches the appliance's rate specification. • Before operating the product remove it from its packaging and check it is in good condition. • DO NOT operate any product with a damaged cord or plug. We recommend not using an extension cord with this appliance.
SAFETY RULES • DO NOT attempt to repair or adjust any electrical or mechanical functions of the cooler, as this may void the warranty. • DO NOT cover the air inlet or outlet on the appliance as this may cause motor damage. • DO NOT insert or allow objects to enter any ventilation or exhaust opening as this may damage the product and could cause an electrical shock or fire. • DO NOT operate with the Honeycomb media removed as this will overload and damage the motor.
PARTS DESCRIPTION 1 9 2 10 11 3 6 7 12 4 8 15 1. 2. 3. 4. 5. 6. 7. 5 Control Panel Outlet Louvers Front Pad Cover Casters Wheels Water Fill Door Hose Adapter 13 14 8. Water Level Indicator 9. Can Holders 10. Top Storage Compartment 11. Rear Pad Cover 12. Cord Wrap 13. Overflow Hole 14. Drainage cap 15.
USE & OPERATION CONTROL PANEL FUNCTIONS TIMER SWING POWER SPEED COOL TIMER : Press the ''TIMER'' button until the indicator light comes on to your desired timer. Once the set time has passed, the unit will automatically shut off. The Timer function allows you to program the unit for 0.5 to 8 hours OFF timer. SWING : Touch SWING button on the touchscreen panel to turn on the automatic swing function to direct the air stream. The louvers will begin to move automatically from side to side.
USE & OPERATION SPEED: Touch SPEED to change fan speed between HIGH and LOW as displayed in incremental bars HIGH and LOW. COOL: To use the unit as an evaporative cooler, touch COOL on the touchsreen panel. The pump will turn on and distribute water to wet out the cooling pad. LOW WATER LEVEL WARNING FEATURE : The CO301PC features low water level warning function. Whenever water is below minimum level, the COOL display will continuously flash and a warning sound will beep for 10 seconds.
USE & OPERATION FILL WATER ( Continuous Water Supply Connection) • Connect a garden hose to the hose adapter securely. Make sure hose adapter seal washer is evenly set inside the adapter. • Connect water supply to the garden hose, and turn on water supply. • Water inside the tank will automatically refill once, it reaches the Min. Level. • Similarly, the water supply to the tank will stop, once the tank is full, and reaches Max. Level.
USE & OPERATION LOW WATER ALARM FUNCTION The unit is equipped with a low water sensor. When water in the tank is below the minimum level, you will hear 10 beeps and the COOL LED indicator will flash continuously. At the same time the power to the pump inside the unit will be cut off to protect the life of the pump. To disengage the alarm function, turn off and unplug the unit from the power outlet, and fill the tank with water above the minimum level.
USE & OPERATION REMOTE CONTROL Remote Control POWER - Turn power on/off SPEED - LOW/HIGH COOL - Turn the pump/COOL function on SWING - Automatic swing of louvers TIMER - Timer function of 0.5 to 8 hours NOTE: Under direct sunlight, effective remote control range will be reduced. NOTE Batteries not included in the package. Please insert two new AAA dry cell batteries for fully functional remote control.
USE & OPERATION OPERATING THE UNIT • Fill the tank manually or after hose connection is made, turn on the water supply to the cooler. • The hose connection to the float valve provides an automatic method of refilling the water supply as water is evaporated.Whenever possible operate the blower fan at low speed for maximum cooling. • When cooling is not required you can operate the unit as a fan only by turning on the fan and leaving the pump turned off.
CLEANING & MAINTENANCE WARNING • Before cleaning the unit, switch it to the ''OFF'' position and remove the plug from the power socket. • To clean the outside, use a damp cloth to remove dirt and dust. • Never use detergents, corrosive elements or any chemicals to clean this product. • When the product is not in use, store the unit in a dry place out of direct sunlight. to clean this product. • If you do not intend to use the product for some time, empty the water tank.
CLEANING & MAINTENANCE CLEANING THE FILTER The unit includes honeycomb pads, located in the front and rear of the unit. The frequency of cleaning the model depends on local air and water conditions. In areas where the mineral content of the water is high, deposits may build up and restrict air flow. In this case, it is recommended that the honeycomb be cleaned every two months. To clean the honeycomb, simply wash and rinse with water. Soft brush may be used to loosen mineral deposits.
TROUBLESHOOTING GUIDE PROBLEM POSSIBLE CAUSE SOLUTION No discharge of air Cord is not plugged in. Make sure power cord is plugged in and the supply switch in ON. Power is not on. Try to turn the unit ON by pressing buttons on control panel or remote control. Pump is not turned ON. Turn on COOL function from remote or control panel. Low or no water in tank, when COOL is selected. Refill water tank. Damaged Pump or Calcium deposits on blower. Contact service centre. New Unit.
TROUBLESHOOTING GUIDE PROBLEM POSSIBLE CAUSE SOLUTION The unit does not respond Remote control batteries. Check batteries, Replace if needed. Try to operate using the control panel. Damaged PCB Try with remote control. If the unit responds, PCB board fasteners may be loose. Contact service centre. If neither remote control nor control panel works, PCB board may be damaged. Contact service centre.
TECHNICAL SPECIFICATIONS MODEL NO. Voltage Frequency Wattage Water Tank Capacity Cooling Media Product Dimension Net Weight Current ELECTRICAL WIRING DIAGRAM 18 CO301PC 220-240V 50Hz 270 Watts 30 Litre Honeycomb 546 (L) x 437 (W) x 1082 (H) mm 30 Kg 1.2/2.
: © 2012 AirTek International Corporation Limited The Honeywell Trademark is used under license from Honeywell International Inc. Honeywell International Inc. makes no representation or warranties with respect to this product. Manufactured by AirTek International Corporation Limited.
