Installation Guide

SAFEmine Ltd | www.safe-mine.com | [e-mail] 21/39
SAFEmine (part of Hexagon Mining)
Baarerstrasse 133, CH-6300 Zug
Switzerland
www.hexagon.com
3.6. Cables
3.6.1. QD221 and QD222 Display Extension Cables
The QD221 and QD222 display extension cables provide 1.5m and 5m of cable in order to place the
QD200 RemoteDisplay or QD204 ScopeScreen visible to the operator and remotely from the main
CAS unit. The cable features a male and a female 4-pin plug with a pinout corresponding to the serial
interface described in this chapter.
3.6.2. QM101 WiFi Stick Antenna Extension Cable
The WiFi stick antenna extension cable is an accessory for the QF0838 WiFi stick antenna. the cable
acts as adapter from N-type connector to SMA and is 2.9m long.
3.6.3. QM103 and QS422 CAN-Bus Y-Cables
The CAN bus cables are required when using the QS430 SerialExtender. The QM103 cable is
equipped with a 120Ω bus terminator resistance were as the QS422 has no such termination. The
cable features a male and a female M12 plug with 8 threads and a female M8 plug with 4 pins.
QM103 is used when the QS430 SerialExtender is the only device connected to the can bus. In the
contrary case, when both the QS430 SerialExtender and the QR310 TrackingRadar are connected to
the CAS unit then the QS422 cable must be used. This is because the CAN bus is terminated by the
TrackingRadar installation.
In any case consult with your support responsible or write to [e-mail] in order to
verify your installation.
3.6.4. QM104 MainUnit Power Cable
The QM104 MainUnit power cable is to be connected to battery voltage bypassing the regular vehicle
isolation switch. When required, to remain within safety regulations, it is recommended to install a
separate isolation switch dedicated only to the SAFEmine system.
The QM104 features a female M12 plug and an open ended 2m long pigtail of cable with 8 individual
colored threads. The colors indicate the associated pin. Please refer to the tables provided by the
Main and I/O Connector Documentation in this chapter.