Safety Data Sheet

ManualsBrandsHercules ManualsChemicals & CompoundsGrrip Thread Sealant (16 oz.)

SAFETY DATA SHEET

1. Identification

Product identifier Hercules Grrip

Other means of identification

Product code

7383E

Synonyms

Part Numbers: 15510, 15515, 15520, 15525

Recommended use

Pipe thread sealant.

Recommended restrictions

None known.

Manufacturer/Importer/Supplier/Distributor information

Company Name

HCC Holdings, Inc. an Oatey Affiliate

Address

4700 West 160th Street

Cleveland, OH 44135

Telephone

216-267-7100

E-mail

info@oatey.com

Transport Emergency

Chemtrec 1-800-424-9300 (Outside the US 1-703-527-3887)

Emergency First Aid

1-877-740-5015

Contact person

MSDS Coordinator

2. Hazard(s) identification

Category 4Flammable liquids

Physical hazards

Category 2ASerious eye damage/eye irritation

Health hazards

Category 1Sensitization, skin

Not applicableHazardous to the aquatic environment, acute

hazard

Environmental hazards

Not applicableHazardous to the aquatic environment,

long-term hazard

Not classified.

OSHA defined hazards

Label elements

Signal word

Warning

Hazard statement

Combustible liquid. May cause an allergic skin reaction. Causes serious eye irritation.

Precautionary statement

Prevention

Keep away from flames and hot surfaces-No smoking. Avoid breathing mist or vapor. Wash

thoroughly after handling. Contaminated work clothing must not be allowed out of the workplace.

Wear protective gloves/eye protection/face protection.

Response

If on skin: Wash with plenty of water. If in eyes: Rinse cautiously with water for several minutes.

Remove contact lenses, if present and easy to do. Continue rinsing. If skin irritation or rash

occurs: Get medical advice/attention. If eye irritation persists: Get medical advice/attention. Wash

contaminated clothing before reuse. In case of fire: Use appropriate media to extinguish.

Storage

Store in a well-ventilated place. Keep cool.

Disposal

Dispose of contents/container in accordance with local/regional/national/international regulations.

Hazard(s) not otherwise

classified (HNOC)

Frequent or prolonged contact may defat and dry the skin, leading to discomfort and dermatitis.

Static accumulating flammable liquid can become electrostatically charged even in bonded and

grounded equipment. Sparks may ignite liquid and vapor. May cause flash fire or explosion.

3. Composition/information on ingredients

Mixtures

Hercules Grrip SDS US

924572 Version #: 01 Revision date: - Issue date: 05-February-2015

1 / 9

Summary of content (9 pages)

PAGE 1
SAFETY DATA SHEET 1. Identification Product identifier Hercules Grrip Other means of identification Product code 7383E Part Numbers: 15510, 15515, 15520, 15525 Synonyms Recommended use Pipe thread sealant. Recommended restrictions None known. Manufacturer/Importer/Supplier/Distributor information Company Name Address Telephone E-mail Transport Emergency Emergency First Aid Contact person HCC Holdings, Inc. an Oatey Affiliate 4700 West 160th Street Cleveland, OH 44135 216-267-7100 info@oatey.
PAGE 2
Chemical name CAS number % Castor Oil 68187-84-8 20-30 Rosin 8050-09-7 20-30 67-63-0 10-20 14807-96-6 10-20 Magnesium carbonate 546-93-0 5-15 Graphite 7782-42-5 1-5 Silica, amorphous, fumed 112945-52-5 1-5 Crystalline silica (Quartz) 14808-60-7 <0.5 Isopropyl alcohol Talc Other components below reportable levels *Designates that a specific chemical identity and/or percentage of composition has been withheld as a trade secret. 0.27 4.
PAGE 3
6. Accidental release measures Personal precautions, protective equipment and emergency procedures Methods and materials for containment and cleaning up Keep unnecessary personnel away. Keep people away from and upwind of spill/leak. Eliminate all ignition sources (no smoking, flares, sparks, or flames in immediate area). Wear appropriate protective equipment and clothing during clean-up. Avoid breathing mist or vapor.
PAGE 4
US. OSHA Table Z-3 (29 CFR 1910.1000) Components Type Value Form Crystalline silica (Quartz) (CAS 14808-60-7) TWA 0.3 mg/m3 Total dust. TWA TWA 0.1 mg/m3 15 mppcf 0.8 mg/m3 Respirable. Graphite (CAS 7782-42-5) Silica, amorphous, fumed (CAS 112945-52-5) Talc (CAS 14807-96-6) TWA 20 mppcf 0.3 mg/m3 0.1 mg/m3 20 mppcf 2.4 mppcf Total dust. Respirable. Respirable. US.
PAGE 5
Wear appropriate chemical resistant clothing. Use of an impervious apron is recommended. Other Respiratory protection Thermal hazards If engineering controls do not maintain airborne concentrations below recommended exposure limits (where applicable) or to an acceptable level (in countries where exposure limits have not been established), an approved respirator must be worn. Wear appropriate thermal protective clothing, when necessary. When using do not smoke.
PAGE 6
11. Toxicological information Information on likely routes of exposure Prolonged inhalation may be harmful. Inhalation Skin contact May cause an allergic skin reaction. Eye contact Causes serious eye irritation. Ingestion Expected to be a low ingestion hazard. Symptoms related to the physical, chemical and toxicological characteristics Severe eye irritation. Symptoms may include stinging, tearing, redness, swelling, and blurred vision. Irritation of nose and throat.
PAGE 7
Components Species Test Results LC50 Bluegill (Lepomis macrochirus) > 1400 mg/l, 96 hours EC50 Daphnia 4.5 mg/l, 48 Hours Isopropyl alcohol (CAS 67-63-0) Aquatic Fish Rosin (CAS 8050-09-7) Aquatic Crustacea * Estimates for product may be based on additional component data not shown. No data is available on the degradability of this product. Persistence and degradability Bioaccumulative potential Partition coefficient n-octanol / water (log Kow) Isopropyl alcohol (CAS 67-63-0) No data available.
PAGE 8
SARA 302 Extremely hazardous substance Not listed. SARA 311/312 Hazardous chemical No SARA 313 (TRI reporting) Chemical name Isopropyl alcohol CAS number % by wt. 67-63-0 10-20 Other federal regulations Clean Air Act (CAA) Section 112 Hazardous Air Pollutants (HAPs) List Not regulated. Clean Air Act (CAA) Section 112(r) Accidental Release Prevention (40 CFR 68.130) Not regulated. Not regulated. Safe Drinking Water Act (SDWA) US state regulations US.
PAGE 9
NFPA ratings 2 2 Disclaimer Hercules Grrip 924572 Version #: 01 0 HCC Holdings Inc. an Oatey Affiliate cannot anticipate all conditions under which this information and its product, or the products of other manufacturers in combination with its product, may be used. It is the user’s responsibility to ensure safe conditions for handling, storage and disposal of the product, and to assume liability for loss, injury, damage or expense due to improper use.