Manual

• Heatmaster/American Gas Log, Outdoor Burner/Hearth Kits •IM-116. Rev G . 01/2019
3
Improper installation, adjustment, alteration, service
or maintenance can cause injury or property damage.
Refer to the owner’s information manual provided with
this appliance. For assistance or additional information
consult a qualied installer, service agency or the gas
supplier.
WARNING
Fire Risk
Exhaust Fumes Risk
• Do NOT use this appliance as a “vent-
free” heater.
WARNING
2.26
2 2
Getting Started
A. Size of Firebox
See Table 1 in Section 1.B.
B. Tools and Supplies Needed
Tools and supplies normally required for installation:
Pliers
Phillips screwdriver
Tape measure
Crescent wrenches
Gas shuto󰀨 valve
Non-corrosive leak check solution
3/4 in. wrench, 7/16 in. wrench
C. Inspect the Appliance and Components
• Remove the contents from the carton. Attached to the
burner are tags identifying the manufacturer name, serial
number, model number (including gas log size), BTU
ratings, gas type, etc.
• Review the attached tags before proceeding. Ensure
that all minimum replace dimension requirements are
achieved using Table 1 in Section 1.B. See Figure 2.1.
Ensure the gas type provided in the replace coincide
with the gas type marked on the tag.
Figure 2.1 Measure Firebox
Sharp Edges
• Wear protective gloves
and safety glasses during
installation.
CAUTION
Asphyxiation Risk
This appliance produces carbon monoxide
(CO).
• The free opening areas (in square inches)
of the chimney damper as shown in the
tables must be met.
• User must make sure damper is locked
open.
• The installer is responsible to ensure
proper ventilation of ue gases before
appliance is used.
Fire needs to draft properly for safe
operation.
WARNING
Heatmaster/American Gas Log, disclaims
any responsibility for, and the warranty will
be voided by, the following actions:
• Installation and use of any damaged appliance or
vent system component.
• Modication of the appliance or vent system.
• Installation other than as instructed by Heatmaster/
American Gas Log,.
• Improper positioning of the gas logs or the glass
door.
• Installation and/or use of any component part not
approved by Heatmaster/American Gas Log,.
Any such action may cause a re hazard.
WARNING
D. Components of the Gas Hearth Kit
The Heatmaster/American Gas Log,, Burner/Hearth Kit con-
sists of the following:
• Burner/Pan Assembly
• Grate Assembly
• Lava Rock
• Damper Stop
DO NOT INSTALL SUBSTITUTE COMPONENTS.